Abstract:This work investigates the effects of two kinds of iron ore on the pyrolysis characteristics of a low-rank bituminous coal from Hami, China. The pyrolysis and its product distribution were studied using a thermogravimetric analyzer and a fixed bed reactor. A gas chromatograph and a gas chromatograph mass spectrometer were employed to test the properties and composition of the pyrolytic products. Results showed that the pyrolysis temperature of the raw coal ranged mainly from 350 to 650 degrees C. The weight-loss rate reached a maximum of 6.95%/min at 443 degrees C. The weight loss was 44.27% at the final pyrolysis temperature of 750 degrees C. The tar yield of raw coal was 9.51% in the fixed bed reactor at 600 degrees C. Adding iron ore, which was intended for a lower tar yield and a higher fraction of light tar (boiling point <360 degrees C), had a catalytic effect on the pyrolysis of raw coal. With separate addition of hematite and specularite, both having a mass of 20% of the raw coal, coal weight loss increased by 3.86% and 5.56%, respectively, when the catalytic upgrading was at 600 degrees C, and good upgrading effect was obtained. Meanwhile, benzene homologue in tar increased slightly, by 0.62% and 1.44%, compared to that in the tar of the raw coal. The upgrading effects of iron ore on tar also lowered element O content in the resulting tar, by 36.89% with the addition of hematite and by 43.16% with specularite. The iron concentrate recovered was measured by magnetic separation method. The iron concentrate grade was 52.97% with hematite added in coal when the residence time of ultimate pyrolysis temperature was 25 min and the magnetic field strength was 96.48 kA/m, while it was 58.02% with specularite added when the residence time was 35 min and the magnetic field strength was 109.27 kA/m, both with a char grinding fineness of less than 0.074 mm (ground char accounting for approximately 80% of total char); iron concentrate recovery rate was 85.31% and 76.74%, respectively. The experimental results proved the feasibility of recovering iron ore in char by magnetic separation.

The effect of CO2 on pyrite transformation

Pyrolysis Behavior of Pyrite under a CO-H 2 Atmosphere

Catalytic effect of cobalt ion on oxidative pyrolysis of cation exchange resin

Experimental Studies on Phase Transformation During Pyrite Concentrate Oxidation under Circulating Fluidized Bed (CFB) Roasting Conditions

Reaction Characteristics of Phosphogypsum Under Carbon Monoxide Atmosphere

The thermal transformation behavior and products of pyrite during coal gangue combustion

Sulfur Transformation During Coal Pyrolysis with Char Heat Carrier

Effect of iron minerals during coaling on the transformation of NO in the presence of NH3: Take pyrite as an example

Comprehensive study on the effect of CO2 on coal pyrolysis at fast heating rate

Effect of carbonate ions on pyrite (FeS2) dissolution

Study on the Transformation of Arsenic and Lead in Pyrite During Thermal Conversion

Effects of CO2 Atmosphere on Slow Pyrolysis of High-Ash Lignite

PREPARATION FOR PYRITE BY SOLVOTHERMAL METHOD

Thermal decomposition and oxidation of pyrite with different morphologies in the coal gangue of North China

CO2-mediated sulfur evolution chemistry of pyrite oxidation during oxy-fuel combustion

Effect of carbon dioxide on pyrolytic products characteristics and DOM binding heavy metals copper in sewage sludge biochar

International Conference on Fluidized Bed Technology EFFECT OF FE 2 O 3 ON SULFUR TRANSFORMATION DURING COAL PYROLYSIS IN A FLUIDIZED BED REACTOR

Effects of CO Atmosphere on the Pyrolysis of a Typical Lignite

Effect of Ash and Dolomite on the Migration of Sulfur from Coal Pyrolysis Volatiles

Effects of Iron Ores on the Pyrolysis Characteristics of a Low-Rank Bituminous Coal

Characterization of pyrolytic properties of pyrite in the terahertz frequency band