Abstract:The forms of arsenic (As) and lead (Pb) in coal have an important influence on their transformation during combustion. Considering that As and Pb in coal are partially associated with pyrite, pyrolysis and oxidation experiments were conducted on pyrite in a fixed-bed reactor between 600 and 1000 degrees C to study the transformation of As and Pb in pyrite during thermal conversion. During pyrolysis, As remained essentially unreleased below 700 degrees C, and the release ratio increased with increasing temperature above 700 degrees C. At 1000 degrees C, As was almost completely released into the gas phase. During oxidation, As remained essentially unreleased below 800 degrees C, and the release ratio increased with increasing temperature above 800 degrees C, reaching 61.67% at 1000 degrees C. The gas-phase release ratio of As showed a dynamic change that rapidly increased with time, and the change was significantly correlated with the dynamic transformation of the pyrite. During pyrolysis, As was released into the gas phase by a two-step decomposition of FeAs2. In an oxidizing atmosphere, FeAs2 was oxidized to form As2O3 and Fe2O3, which could further react to form FeAsO4. As was retained in the solid phase, and the release ratio of As was therefore lower. During pyrolysis, Pb was released between 600 and 1000 degrees C, and the release rate and release ratio increased with increasing temperature. During oxidation, Pb remained unreleased at 600 degrees C, and the release ratio increased with increasing temperature above 700 degrees C, reaching 87.69% at 1000 degrees C. No significant correlation was found between the release of Pb and the conversion of the pyrite, as Pb exists in the form of PbS in pyrite. During pyrolysis, Pb was released into the gas phase by the decomposition of PbS. Part of the PbS in an oxidizing atmosphere was oxidized into PbO or PbSO4, which remained in the solid phase, resulting in a relatively low release ratio.

Pyrolysis Behavior of Pyrite under a CO-H 2 Atmosphere

Reaction behavior of sulfides in blast furnace raw materials under hydrogen-rich reducing atmosphere

Experimental Studies on Phase Transformation During Pyrite Concentrate Oxidation under Circulating Fluidized Bed (CFB) Roasting Conditions

The thermal transformation behavior and products of pyrite during coal gangue combustion

CO2-mediated sulfur evolution chemistry of pyrite oxidation during oxy-fuel combustion

Characterization of pyrolytic properties of pyrite in the terahertz frequency band

Sulfur Transformation During Coal Pyrolysis with Char Heat Carrier

Pyrite transformation and sulfur dioxide release during calcination of coal gangue

Study on the Transformation of Arsenic and Lead in Pyrite During Thermal Conversion

Dynamic Simulation of the Thermal Decomposition of Pyrite Under Vacuum

Thermal decomposition and oxidation of pyrite with different morphologies in the coal gangue of North China

PREPARATION FOR PYRITE BY SOLVOTHERMAL METHOD

Investigation on the transformation behaviours of Fe-bearing minerals of coal in O2/CO2 combustion atmosphere containing H2O

Dynamic Characteristics and Elements Releasing Performance in Pulverized Coal Pyrolysis Process at High Temperature

International Conference on Fluidized Bed Technology EFFECT OF FE 2 O 3 ON SULFUR TRANSFORMATION DURING COAL PYROLYSIS IN A FLUIDIZED BED REACTOR

Experiment of H2S Evolution During Coal Pyrolysis in Fluidized Bed

Green and efficient comprehensive utilization of pyrite concentrate: A mineral phase reconstruction approach

Experimental research on the spontaneous combustion of coal with different metamorphic degrees induced by pyrite and its oxidation products

In situ observations of thermally induced phase transformations in iron sulfide nanoparticles

Lignite Pyrolysis and Oxy-Fuel Combustion Characteristics under N2 and CO2 Atmospheres

Mercury Forms and Their Transformation in Pyrite under Weathering