Abstract:The aim of the study is mainly to understand the effect of pressure and temperature on the property of coal particles in pyrolysis/gasification. The pyrolysis of Shenfu (SF) coal sample and the gasification of resultant char were carried out in a thermogravimetric analyzer (TGA) under pressurized and ambient conditions. The gas released from coal pyrolysis was analyzed using a portable FTIR spectrometer connected to the TGA. Simultaneously, the surface structure and main chemical compounds of the pyrolyzed char particles were analyzed using gas sorption (ASAP2020), CNHS, etc. analysis instruments. First, the pyrolysis of SF coals was carried out in a pressurized TGA at various pressures (0.1, 0.8, 1.5, 3 and 5 Mpa) with a heating rate of 10 degrees C min(-1) and a final temperature of 1000 degrees C. It was observed that higher pressures accelerated the devolatilization of coal samples at lower temperatures (< 500 degrees C), while the maximum mass loss rate was reduced, and the solid char yield increased with increasing pressure. The specific surface area and chemical components changed with changing system pressure. The gasification reactivity of the solid char particles obtained was analyzed using ambient thermal balance at 1000 degrees C, using CO2 as the gasifying agent. The gasification reactivity increased with increasing pyrolysis pressure. Then the pyrolysis of SF coal was carried out under different temperatures (500, 650, 800 and 1000 degrees C) at ambient and higher pressures (3 Mpa). With increasing temperature, the gas product from coal pyrolysis enhanced greatly at the expense of decreasing charcoal residue. The surface area of the char particles obtained were minimum at 800 degrees C (ambient pressure) and at 600 degrees C (3 Mpa). The gasification reactivity of solid charcoal residues decreased considerably with increasing pyrolysis temperature at ambient pressure, while at 3 Mpa a different result was obtained, with the highest gasification reactivity at 800 degrees C. (c) 2007 Curtin University of Technology and John Wiley & Sons, Ltd.

Dynamic Characteristics and Elements Releasing Performance in Pulverized Coal Pyrolysis Process at High Temperature

Experimental Research on Dynamic Yield Performance of Light Reburning Coal Volatiles

Investigation on the Release Characteristics of Light Hydrocarbon During Pulverized Coal Pyrolysis

Fast Pyrolysis of Pulverized Coal at High Temperatures and Fuel Nitrogen Migration Characteristics in a Wire Mesh Reactor

High-temperature pyrolysis behavior of two different rank coals in fixed-bed and drop tube furnace reactors

Release Behavior of Hydrocarbon Components of Superfine Pulverized Coal Pyrolyzed under Reburning Conditions

Volatility Of Trace Elemets In Huainan And Guizhou Coals During High Temperature Pyrolysis

Release of Nitrogen Containing Components During the Pyrolysis of Residues of Shenhua Coal Liquification

STUDY ON RELEASE BEHAVIOR OF GAS COMPONENTS OF BIOMASS IN FAST PYROLYSIS

INFLUENCE OF PYROLYSIS CONDITIONS ON VOLATILITY OF TRACE ELEMENTS IN COALS

KINETIC STUDY ON GASEOUS HYDROCARBONS RELEASE OF SHANXI HUNYUAN CANNEL COAL DURING LOW TEMPERATURE PYROLYSIS PROCESS IN O_2-ENRICHED CONDITIONS

Study on the Formation and Dissipation Mechanism of Gas Phase Products During Rapid Pyrolysis of Superfine Pulverized Coal in Entrained Flow Reactor

The Influence of Pressure and Temperature on Coal Pyrolysis/Gasification

Transformation behavior of trace elements during coal pyrolysis

Influence of Heat Transfer Inside Particles on Coal Pyrolysis at Ultra-High Temperature

Volatile Gas Release Characteristics of Three Typical Chinese Coals under Various Pyrolysis Conditions

Study on Characteristics and Influencing Factors of Coal-Water Slurry Pyrolysis

Volatility of trace elements in the coal from Shenfu during pyrolysis

Experimental study on flash pyrolysis of pulverized coals in Py-GC

Pyrolysis Characteristics and Evolution of Char Structure During Pulverized Coal Pyrolysis in Drop Tube Furnace: Influence of Temperature

REAL-TIME ANALYSIS OF ORGANIC MATTER RELEASED DURING PYROLYSIS OF COAL WITH DIFFERENT RANK BY HIGH RESOLUTION MASS SPECTROMETER UNDER VACUUM CONDITION