Abstract:During the fracking process in shale, an interaction occurs between shale and fracking fluid that contains a cocktail of chemicals. One of the chemicals used in fracking fluid is often surfactant, which is generally used as a viscofier. However, surfactants also have the potential of significantly influencing the wettability and thus gas desorption–key factors affecting ultimate gas recovery from shale reservoirs. Even though a few studies discussed the ability of surfactants to alter wettability in shale, the implication of that change in adsorption/desorption behavior has never been experimentally investigated beyond hypothetical inferences. In this study, the influence of the wettability change by anionic surfactant on gas adsorption/desorption behavior in shale was investigated through a series of experiments. Baseline wettability readings of two shale samples were established by measuring the contact angles (BG-1 = 22.7°, KH-1 = 35°) between a drop of pure water placed on their polished surfaces, indicating that the affinity of pure water for the BG-1 surface was greater than that for KH-1. This difference can be attributed to the higher clay content and lower total organic carbon found in BG-1 as compared to KH-1. To investigate the impact of the interaction between shale and surfactants on wettability during the fracking process, we measured the contact angles again, this time with 1 wt % solution of internal olefin sulfate surfactant. The surfactant-induced wettability changes of the two shale samples were investigated by measuring the contact angles again (BG-1 = 3.5°, KH-1 = 19.2°) between a drop of surfactant solution and their polished surfaces. The effect of wettability changes on gas adsorption/desorption was then evaluated utilizing the United States bureau of mines’ modified method. Experiments were conducted on the two shale samples in two ways: after pure water treatment, and after surfactant treatment. The results suggest that due to the wettability alteration of the two shale samples by IOS surfactant toward more water-wet during the treatment, the methane adsorption/desorption characteristics were influenced. In BG-1 sample, IOS solution dramatically changed its wettability to become completely water-wet. Therefore, the volume of desorbed methane dropped by nearly 54%. A similar but less pronounced influence was found in the KH-1 sample, where its desorbed methane dropped by 10% because of wettability alteration toward more water-wet. These reductions in the amount of desorbed gas suggest that prior to selecting a surfactant for addition to fracking fluid, its effect on wettability and gas desorption should be investigated to optimize shale gas recovery potential.

Wettability Alteration of Sandstone by Chemical Treatments

Effect of Heavy Constituent in Crude Oil on Wettability Change of Sandstone

Wettability alteration and mitigating aqueous phase trapping damage in tight gas sandstone reservoirs using mixed cationic surfactant/nonionic fluoro-surfactant solution

Wettability Alteration to Reduce Water Blockage in Low-Permeability Sandstone Reservoirs

Synthesis of a Superhydrophobic Fluorinated Nano-Emulsion and Its Modification on the Wettability of Tight Sandstone

Study on the Wettability Alteration of Tight Sandstone by Low-Frequency Vibration and Nanofluid

Wettability alteration of carbonate rocks from strongly liquid-wetting to strongly gas-wetting by fluorine-doped silica coated by fluorosilane

The effect of sedimentary microfacies on wettability of tight sandstone in coal-bearing strata: a case from Ordos Basin, China

Achieving the Super Gas-Wetting Alteration by Functionalized Nano-Silica for Improving Fluid Flowing Capacity in Gas Condensate Reservoirs

Wettability Alteration in Gas Condensate Reservoirs: A Critical Review of the Opportunities and Challenges

Experimental investigation on molecular-scale mechanism of wettability alteration induced by supercritical carbon dioxide-water-rock reaction

Sandstone chemical consolidation and wettability improvement using furan polymer-based nanofluid

Experimental Evaluation of CO2-Soluble Nonionic Surfactants for Wettability Alteration to Intermediate CO2-Oil Wet during Immiscible Gas Injection

Molecular Design and Synthesis of Wettability Alteration Chemicals

STUDY ON SAND PRODUCTION IN A NATURAL GAS HYDRATE PRODUCTION WELL

Study on the Mechanism of Nanoemulsion Removal of Water Locking Damage and Compatibility of Working Fluids in Tight Sandstone Reservoirs

Phase Behavior, Wettability Alteration, and Oil Recovery of Low-Salinity Surfactant Solutions in Carbonate Reservoirs

Geochemical controls on wettability alteration at pore-scale during low salinity water flooding in sandstone using X-ray micro computed tomography

Wettability and Its Influencing Factors of Tight Sandstones in Coal Measures in Ordos Basin, China.

Design of fluorine-modified nanocrystalline cellulose achieving super gas-wetting alteration of reservoir cores

Effect of Anionic Surfactant on Wettability of Shale and Its Implication on Gas Adsorption/Desorption Behavior