Abstract:Novel ZnS-poly(urethane-methacrylate macromer) (PUMM) nanocomposite films with high refractive index were prepared by incorporating thiophenol (PhSH)-4-thiomethyl styrene (TMSt)-capped ZnS nanoparticles into a urethane-methacrylate macromer (UMM), followed by spin-coating and ultraviolet radiation initiated free radical polymerization. PhSH-TMSt-capped colloidal ZnS solution was synthesized by reacting zinc acetate with H2S in N,N-dimethylformamide. UMM macromer was synthesized by reacting 2-hydroxyethyl methacrylate (HEMA) with isocyanate group terminated polythiourethane oligomer which was obtained from polyaddition of 2,2'-dimercaptoethyl sulfide (MES) with 2,4-tolylene diisocyanate (TDI). Thiol-capped ZnS nanoparticles were characterized and found to be 2.0-5.0 nm in diameter with a cubic phase structure. The chemical composition of these ZnS nanoparticles was determined to be Zn2+ : S2- : RS- = 1 : 0.6 : 0.6 using chemical analysis methods. The weight fraction of ZnS nanoparticles in the films was measured by TGA, and it accords well with that of theoretical calculation. FTIR and DSC studies show that ZnS nanoparticles were successfully immobilized into the polymer matrix and the resulting nanocomposite films have a good thermal stability. TEM images indicate that the ZnS nanoparticles were uniformly dispersed in the polymer matrix and the particles remained their original size (2-5 nm) before incorporation into the polymer matrix. The XPS depth profiling technique demonstrates that the ZnS nanoparticles were also dispersed homogeneously in the depth scales of the polymer matrix. The nanocomposite films show high optical transparency in the visible region (T > 95% at 550 nm) and high refractive index in the range of 1.645-1.796 at 632.8 nm as the content of thiol-capped ZnS nanoparticles linearly increased from 0 to 86 wt%.

Creation of transparent nanocomposite films with a refractive index of 2.3 using polymerizable silicon nanoparticles

Effective increase in the refractive index of novel transparent silicone hybrid films by introduction of functionalized silicon nanoparticles

Fabrication of a Nanocomposite Film Decorated with Highly Dispersive Nanoparticles by Following an Interface-Induced Strategy

Surface Modification of ZrO2 Nanoparticles with TEOS to Prepare Transparent ZrO2@SiO2-PDMS Nanocomposite Films with Adjustable Refractive Indices

Optical Properties Study of Silicon Oxynitride Films Deposited by RF Magnetron Sputtering

Optical Properties of Highly Photosensitive Hybrid Sol-Gel Films

Synthesize Uniform ZrO 2 NPs by Non-coordination Solvents and Modification for High Refractive Film

Preparation and characterization of ZnS?polymer nanocomposite films with high refractive index

High Refractive Organic–Inorganic Hybrid Films Prepared by Low Water Sol-Gel and UV-Irradiation Processes

PbS/Polymer Nanocomposite Optical Materials with High Refractive Index

High Refractive Index Thin Films of ZnS/polythiourethane Nanocomposites

Studies on electro-optical properties of polymer matrix/LC/SiO<sub>2</sub>nanoparticles composites

Air Nanocolumn-SiO2 composite film with adjustable anisotropic refractive index

High performance hierarchical nanoporous antireflective films by a facile sol–gel process

Thermally Stable Transparent Sol–gel Based Active Siloxane–oligomer Materials with Tunable High Refractive Index and Dual Reactive Groups

Preparation and characterization of novel ZnS/sulfur-containing polymer nanocomposite optical materials with high refractive index and high nanophase contents

Studies On Electro-Optical Properties Of Polymer Matrix/Lc/Sio2 Nanoparticles Composites

Physical and Optical Properties of Silica/Polymer Nanocomposite Inverse Opal

Influence of lymphokines on the anti-TNP-Ficoll response of normal and X-linked B lymphocyte-defective mice.

Nanoporous Silicon Dioxide Films for Large Area and Low-Cost Fabrication of Ultra-Low Refractive Index Coatings

Poly(methylmethacrylate)-silica nanocomposites films from surface-functionalized silica nanoparticles