Abstract:Conventional wet-process phosphoric acid (WPA) extraction route encounters unsatisfactory extraction efficiency, phosphorus yield, and raffinate utilization. Herein, a new extraction route for H3PO4 separation from wet-process superphosphoric acid (WSPA) is proposed to improve these dilemmas. We focus on the equilibrium of H3PO4 extraction by tributyl phosphate (TBP) from WSPA and the extraction mechanism of TBP under high H3PO4 loading conditions. Several critical factors affecting the extraction equilibrium were investigated to optimize the extraction process, including the initial phase ratio (R0), the volume fraction of TBP in extradant (φTBP), temperature (T), and the crosscurrent extraction stages. The results show that the single-stage extraction rate of H3PO4 reaches 70% at R0=6, φTBP=80% and T=80oC with separation factors βP/Fe, βP/Al, βP/Mg, and βP/Ca of 12.48, 21.66, 47.57, and 8.89, respectively. In addition, Fourier transform infrared spectroscopy and Raman spectroscopy enlighten the extraction mechanism at high loading conditions. The characteristic peak positions of P=O, P=O⋯H2O, and P=O⋯H3PO4 in the infrared spectra are determined to be centered at 1,283, 1,267, and 1,233 cm−1, respectively. The semi-quantitative analysis implies that the self-polymerization behavior of the extraction complex TBP·H3PO4 and the mutual attraction of reverse micelles (RMs) through their polar cores is the trigger for the formation of a third phase. Furthermore, the red shift of P-(OH)3 asymmetrical stretching vibration in the Raman spectrum indicates the formation of hydrogen bonds among H3PO4 molecules in the organic phase, which corroborates the formation of RMs. Conclusions can be obtained that H3PO4 enters the organic phase under high loading capacity by reversed micellar extraction. The feasibility of this extraction process is further tested by scrubbing, stripping, and cycling performance experiments. The results are promising for the design of a new efficient route for separating H3PO4 from WPA.

Extraction of nitric acid from wet-process phosphoric acid

Non-dispersive Solvent Extraction of P-Toluic Acid from Purified Terephthalic Acid Plant Wastewater with P-Xylene As Extractant

Wet process phosphoric acid purification by solvent extraction using N-octanol and tributylphosphate mixtures

Efficient Extraction of Phosphoric Acid with a Trialkyl Amine-Based Solvent Mixture

Extraction of Inorganic Acids with Neutral Phosphorus Extractants Based on a Reverse Micelle/microemulsion Mechanism.

Purification of Phosphoric Acid by Solvent Extraction

Complex extraction and stripping of H acid wastewater

Extraction and separation of tungsten from acidic high-phosphorus solution

Recovery of Rare Earths from Nitric Acid Leach Solutions of Phosphate Ores Using Solvent Extraction with a New Amide Extractant (TODGA)

Extraction kinetics of nitric acid from the nitric acid-hydrochloric acid-potassium chloride solution by tributyl phosphate

Recovery of Fumaric Acid from Industrial Wastewater by Chemical Extraction and Stripping

A New Process for Purifying Wet-Process Phosphoric Acid by Solvent Extraction

A non-aqueous phase extraction system using tributyl phosphate for H3PO4 separation from wet-process superphosphoric acid: Extraction equilibrium and mechanism

Removal of Fluorine from Wet-Process Phosphoric Acid Using a Solvent Extraction Technique with Tributyl Phosphate and Silicon Oil

Experimental Study on the Mechanism and Thermodynamics of Extraction of Fe 3+ from Phosphoric Acid Solution

A New Hydrometallurgical Process for Extracting Rare Earths from Apatite Using Solvent Extraction with P-350

Efficient Removal of Dissolved Tributyl Phosphate from Nitric Acid Solution by a Membrane Dispersion Micro Extractor

Extraction of Uranium(VI), Thorium(IV), and Trivalent Rare Earths from Nitric Acid Solutions with {[2-(2-Diphenylphosphoryl)-4-ethylphenoxy]ethyl}diphenylphosphine Oxide

Optimization of operating conditions in purification of wet process phosphoric acid in a liquid-liquid extraction column

Separation of Vanadium and Tungsten in Roasting‐acid Leaching Solutions of the Spent Selective Catalytic Reducing Denitration Catalyst by Co‐extraction Using Hydroxyoxime Extractant‐quaternary Ammonium Salt Extractant LIX984–N263 Extractant