Abstract:In this paper, 2 atom % Al-doped ZnO (AZO) was prepared by the co-precipitation method together with sparking plasma sintering (SPS) treatment. The as-synthesized AZO powders show the morphology of hollow hexagonal towers, which result in a high porosity of 50.6% in the bulk sample consolidated by SPS sintering at 400 °C, and the porosity decreases gradually with increasing sintering temperature up to 1000 °C. Positron annihilation measurements reveal that even after sintering at 1000 °C, there are still a considerable number of small pores. A high electrical conductivity of 3 × 105 S m–1 is achieved at room temperature for the AZO sample sintered at 1000 °C, while the absolute values of Seebeck coefficient keep at relatively high values between 59 and 144 μV K–1 in the measurement temperature range of 27–500 °C, leading to a high power factor of 3.4 × 10–3 W m–1 K–2. On the other hand, the pores in AZO act as strong phonon scattering centers, and an extremely low thermal conductivity of 1.5 W m–1 K–1 measured at room temperature is obtained for AZO sintered at 400 °C. Due to the residual pores in the 1000 °C-sintered sample, the thermal conductivity is still relatively low. As a result, a maximum ZT of 0.275 measured at 500 °C is obtained in this sample, which is the highest ZT reported for ZnO around this temperature.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acsami.0c16506?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acsami.0c16506</a>.Thermal gravity analysis for the Al-doped ZnO (Figure S1), TEM images of Al-doped ZnO sintered at different temperatures (Figure S2), and structural characterization and thermoelectric properties of undoped ZnO prepared by co-precipitation combined with SPS treatment (Figures S3–S5) (<a class="ext-link" href="/doi/suppl/10.1021/acsami.0c16506/suppl_file/am0c16506_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Growth and characterization of the Al-doped and Al–Sn co-doped ZnO nanostructures

Surface Topography and Optical Properties of Al-doped ZnO Thin Films by Sol-gel Process

Zn-doped SnO2 Nanoparticles: Structural, Optical, Dielectric and Magnetic Properties

Preparation and Characterization of Na-doped ZnO Thin Films by Sol–gel Method

Microstructure and Electrical Properties of Al-doped ZnO Thin Films

Preparation and Photoluminescence of ZnO with Nanostructure by Hollow-Cathode Discharge

Study on structural and optical properties of Sn-doped ZnO nanoarrays

Growth And Characterization Of Cu-Catalyzed Zno Nanowires

Enhanced Photoluminescence and Raman Properties of Al-Doped ZnO Nanostructures Prepared Using Thermal Chemical Vapor Deposition of Methanol Assisted with Heated Brass

Growth behaviors and characteristics of low temperature spin-sprayed ZnO and Al-doped ZnO microstructures

Influence of (Co+Al) co−doping on structural, micro-structural, optical and electrical properties of nanostructured zinc oxide

X-ray Diffraction, XPS, and Raman Spectroscopy of Coated ZnO:Al (1—7 at%) Nanoparticles

Synthesis, characterization, and photoluminescence investigations of Al/Co-doped ZnO nanopowder

Spectroscopic Studies of the Plasma for the Preparation of Al-N Co-Doped ZnO Films

In-Situ Doping Preparation of Al-Doped Zno Films Via Pulsed Laser Co-Ablation of Zn and Al Targets with Assistance of Oxygen Plasma

Preparation and optical properties of Co doped nano-ZnO arrays

Effect of Al-doping on Crystallinity and Microstructure of ZnO:Al Thin Films

Effect of (Sm, Co) co-doping on the structure and electrical conductivity of ZnO nanoparticles

Effect of Al doping on the structural, optical and photoluminescence properties of ZnS nanoparticles

Significant Enhancement in the Thermoelectric Performance of Aluminum-Doped ZnO Tuned by Pore Structure

Synthesis and Characterization of Dendritic ZnMgO Nanostructures