Abstract:The volumetric oxygen transfer coefficient of plant cells suspension cultures in the bioreactor differs substantially from the values predicted from aqueous solution or sulfite oxidation.Therefore,there is a real need to have a reliable on-line method for measuring volumetric oxygen transfer coefficient during cultures.A new method for determination of the volumetric oxygen transfer coefficient was proposed based on the dissolved oxygen concentration-time during the aeration following nongassing.The volumetric oxygen transfer coefficient of Taxus media cells suspension cultures in a 10 L bioreactor was measured.The influence of the power input per unit volume and the superficial velocity on the volumetric oxygen transfer coefficient was investigated.An experiential correlation among the volumetric oxygen transfer coefficient KLa,the power input per unit volume N3D2,and the superficial velocity vS in the bioreactor were established.The changes of the volumetric oxygen transfer coefficient,the oxygen uptake rate and the specific oxygen consumption rate for suspension cultures of Taxus media cells in a 10 L bioreactor were researched,and the approaches of the determination of the oxygen uptake rate,the specific oxygen consumption rate and the oxygen saturation concentration in the broth were discussed.The result shows that the effect of aeration amount on the volumetric oxygen transfer coefficient is much higher than that of agitation speed;with the increase of cell biomass,the volumetric oxygen transfer coefficient decreases,the oxygen uptake rate increases,and the specific oxygen consumption rate first increases and then decreases.The results are helpful to the operation control,reactor design and amplification of Taxus media cell suspension cultures in the bioreactor.

New correlation of volumetric oxygen mass transfer coefficient for scale-up in aerobic fermentation

Study on Scale-Up of Anaerobic Fermentation Mixing with Different Solid Content

The Study of Micro-Pressure Inner-Loop Bioreactor Oxygen Mass Transfer Characteristics

Research on Fermentation Scale-Up Based on the OUR Obtained from a Shake Flask.

Oxygen Mass Transfer Behaviors of the Aerating Process in Inner-loop Aerobic Biological Fluidized Bed Reactor

Volumetric Oxygen Transfer Coefficient of Taxus Media Cell Suspension Cultures in Bioreactor

Evaluating Oxygen Mass Transfer Parameters for Large-Scale Engineering Application of Membrane Bioreactors

Oxygen mass-transfer performance of low viscosity gas-liquid-solid system in a split-cylinder airlift bioreactor

A 3D analysis of oxygen transfer in a low-cost micro-bioreactor for animal cell suspension culture

Volumetric oxygen transfer coefficient-based optimization of citric acid fermentation in clean broth

Oxygen Transfer in High Solids Loading and Highly Viscous Lignocellulose Hydrolysates

Study on Volumetric Oxygen Transfer Coefficient of the Simulated Plant Cell Two-Phase Culture System

Numerical and experimental assessment of a miniature bioreactor equipped with a mechanical agitator and non‐invasive biosensors

Characterization and Modeling of Oxygen-Transfer in A 20-L Modified Cell-Lift Bioreactor with A Double-Screen Cage

Analyzing of hydrodynamic stress and mass transfer requirements of a fermentation process carried out in a coaxial bioreactor: a scale-up study

Determination of fermentation parameters for scale-up using a specially designed shake flask

Oxygen Uptake and Transfer in Recombinant Pichia Pastoris Cultivation

The scale-up technology on the basis of oxygen uptake rate

Real-time fluid dynamics investigation and physiological response for erythromycin fermentation scale-up from 50 L to 132 m 3 fermenter

An Empirical Model for Oxygen Mass Transfer Rate and Its Influencing Factors in Micro-nanometer Aeration

New Correlations of Volumetric Liquid-Phase Mass Transfer Coefficients in Gas-Inducing Agitated Tank Reactors