Abstract:Complex components, high moisture and low caloric value of raw Chinese MSW (Municipal Solid Waste) lead to the difficulties of keeping stable burning and low pollutant emission. Differential Density Circulated Fluidized Bed (DDCFB) incinerator was first developed by Zhejiang University to overcome such difficulties. The research of organic pollutants, especially dioxins and polycyclic aromatic hydrocarbons emission and control from MSW incinerators has been carried out in ITPE since 1998. The aim of this paper is to provide the scheme of a new co-firing CFB incineration technology, and useful data for environmental evaluation of trace organic pollutants emission from incinerators. The art of co-firing CFB is presented briefly in the first part of this paper. The dioxin content in original Chinese MSW is estimated to be 10 pg I-TEQ/g based on the data from Abad et al. Several test runs are conducted in a real-scale (150ton/day) incinerator co-firing MSW and coal to investigate dioxins and polycyclic aromatic hydrocarbons emission to ambient air. Test results show that dioxins input into the incinerator is estimated around 300∼600 mg I-TEQ/y, dioxins output is estimated 3∼100 mg I-TEQ/y, and dioxins emitted to ambient air is around 0.1∼15mg I-TEQ/y. It seemed that most of dioxins in original waste are decomposed by incineration process. For seventeen priority PAHs, its emission to ambient air is around 200∼4160g/y for co-firing runs, which is much more than 80g/y for coal combustion only. This suggests that PAHs emission to ambient air needed to be more concerned than dioxins. That is to say, PAHs emission regulatory should be proposed as soon as possible to restrict all incinerators. Several new incinerators (200 tons/day per unit and 300 tons/day per unit) were built by using new Co-firing CFB technology in past few years. From the environmental evaluation report, dioxins emission in stack gas is in range of 0.0025∼0.06 ng I-TEQ/Nm3, which seemed far below the European limit. The annual dioxin emission to air for 200ton/day or 300 t/d units is around 3∼6 mg I-TEQ. It shows that co-firing CFB incinerator is capable of reducing dioxin emission effectively. Based on industrial demonstration experience of new co-firing CFB incineration technology, it has been proven environmental friendly method for thermal treatment of MSW in developing countries. Some reasons for low dioxin emission of co-firing processes are discussed in this paper.

Experimental Study on Co-firing of Lanolin Waste and Municipal Solid Waste in a Circulating Fluidized Bed Incinerator

Utilization of Cow Bone Waste and Calcium Oxide for the Solidification and Stabilization of MSWI Fly Ash: Towards Sustainable Practices

Influence on gaseous pollutants emissions and fly ash characteristics from co-combustion of municipal solid waste and coal by a drop tube furnace

Pollutant Emissions During Co-Incineration Of Landfill Material Refuse-Derived Fuel In A Lab-Scale Municipal Solid Waste Incineration Fluidized Bed Furnace

Pcdd/Fs Inhibition For Co-Firing Municipal Solid Waste And Coal In Circulating Fluidized Bed Incinerators

Experimental Investigation on Co-firing of Coal and Refuse-derived Fuel in a Pilot-scale Circulating Fluidized Bed Combustor

Pollutant emission during co-incineration of landfill material RDF in a lab-scale MSWI fluidized bed furnace

Experimental Study on Municipal Solid Waste Incineration with 1MW CFBI

CO-FIRING MSW WITH COAL IN FLUIDIZED INCINERATOR AND POLLUTANT EMISSION CHARACTERISTICS THEREOF

Emission Characteristics of Polychlorinated Dibenzo-p-dioxins and Dibenzofurans from the Co-combustion of Municipal Solid Waste in a Lab-Scale Drop-Tube Furnace

Numerical and Experimental Investigation on Co-Combustion Characteristics of Hydrothermally Treated Municipal Solid Waste with Coal in a Fluidized Bed

Trace Organic Pollutants Emission from Large-Scale Circulating Fluidized Bed Incinerators of Co-Firing Chinese MSW and Coal

Carbon Monoxide Formation and Emissions During Waste Incineration in a Grate-Circulating Fluidized Bed Incinerator.

On the Furnace Design of Calculation of Circulating Fluidized Bed Boiler Fired Municipal Solid Waste

Effects of Blending Hydrothermally Treated Municipal Solid Waste with Coal on Co-Combustion Characteristics in A Lab-Scale Fluidized Bed Reactor

Study on characterization of ash from co-combustion of coal with municipal solid waste

High temperature melting of municipal solid waste incineration (MSWI) fly ash and co-disposal technology with blast furnaces

Experimental Research of Pipe-Distributed MSW Fluidized Bed Incinerator

Effect of Sewage Sludge Addition on the Co-Combustion Characteristics of Municipal Solid Waste Incineration

Co-combustion of oily sludge and coal in fluidized bed

Pilot-tests of the coal-fired power plant indirect coupling with multi-source organic solid waste incineration technology