Abstract:Many practical lean-premixed combustion systems involved in land-based power plants, gas turbines and boilers are susceptible to self-excited combustion instability, which is characterized by detrimental periodic pressure oscillations. Little attention has been paid on experimentally characterizing the chemical emissions and thermodynamic properties of a thermoacoustic swirl combustor. In this work, the effects of (1) fuel-air equivalence ratio Phi and fuel flow rate Q(CH4) on generating such combustion instability and its impact on chemical emissions and thermodynamic properties in a swirling combustor are experimentally studied. For this, a methane-fueled lab-scale swirl combustor is designed and tested. To monitor the thermodynamic properties of the combustor, an acoustic pressure sensor, an infrared thermal imaging camera, K-type thermal couples, and an infrared flue gas analyzer are applied. It is found that the fuel-air ratio plays an important role on generating combustion instability at different frequencies and amplitudes. This is confirmed by conducting autocorrelation and frequency spectrum analyses of the acoustic pressure time trace. Furthermore, the dominant mode swap (mode-switching) between a low frequency omega(1) and a high non-harmonic one is experimentally observed. Whether the mode switching from high (harmonic or non-harmonic) to low frequency or low to high frequency is found to depend strongly on Q(CH4). As the equivalence ratio is changed from lean to rich, i.e. 0.8 <= Phi <= 1.2, NOx emission is increased from 1 ppm to 37 ppm. However, CO emission is decreased by 2 order of magnitudes from 1000 ppm first and then increased. The minimum CO emission is approximately 3.0 ppm. In addition, O-2 concentration is decreased by more than 80% with increased Phi, depending on the methane flow rate. This means that the combustion efficiency characterized by the O-2 emission is decreased dramatically from 99.5% to 68% with Phi increased from 0.6 to 1.2. The present work sheds light on the characteristics of chemical emissions and thermodynamic properties, when a thermoacoustic swirl combustor is operated with methane-air equivalence ratio Phi varied from lean to rich condition and different Q(CH4). It opens up a practical means to design a stably operated but low-emission thermoacoustic swirl combustor.

Experimental Investigation of Thermoacoustic Instabilities for A Model Combustor with Varying Fuel Components

Spray Swirling Flame Dynamic under Combined Modulation of Air and Fuel

Experimental Study on Self-Excited Thermoacoustic Instabilities and Intermittent Switching of Azimuthal and Longitudinal Modes in an Annular Combustor

Numerical Investigation of the Combustion and Thermoacoustic Characteristics in an Annular Combustor with Hydrogen

Combustion Instability Detection Based on Multi-Signal Information Fusion for an Industrial Gas Turbine Combustor

Experimental Investigation on High Frequency Perturbation to Combustion Instability by Low Frequency Actuator in a Backward-facing Step Combustor

Multi-bifurcation behaviors of stability regimes in a centrally staged swirl burner

Experimental study on thermoacoustic performance of radial staged combustor

Experimental Characterizing Combustion Emissions and Thermodynamic Properties of a Thermoacoustic Swirl Combustor

Experimental Study of Thermoacoustic Instability in Premixed Rijke Combustor

Predicting thermoacoustic stability characteristics of longitudinal combustors using different endpoint conditions with a low Mach number flow

Thermoacoustic Instability Drivers and Mode Transitions in a Lean Premixed Methane-Air Combustor at Various Swirl Intensities

Thermoacoustic Instability in Premixed Rijke Combustor with Variable Power Input

Thermoacoustic instability analysis of a laminar lean premixed flame under autoignitive conditions

Experimental Study on Combustion and Thermoacoustic Instability Characteristics of Ethanol/methane Co-firing Flames

Effects of Operating Parameters on the Combustion Oscillation Behaviour in a Lean Premixed CH4 Combustor

Computational investigations of the coupling between transient flame dynamics and thermo-acoustic instability in a self-excited resonance combustor

Experimental Investigations of Spark Ignition in A Model Combustor with Synthesis Gas

Experimental Study and Analysis of Thermo-Acoustic Instabilities in Natural Gas Premixed Flames

Experimental investigation on macrostructure and evolution of hydrogen-air micro-mix multi-jet flames

Flame visualization and spectral analysis of combustion instability in a premixed methane/air-fueled micro-combustor