Abstract:Low-k dielectric materials were prepared by sintering ZSM-5 zeolite powder compacts at temperatures ranged 1200-1300(degrees)C, and the microwave dielectric characteristics were investigated together with the structure evolution during sintering. It was failed to obtain ZSM-5 ceramics by high temperature sintering because the densification could never occur below the tolerable temperature and the ordered porous structure completely collapsed above the tolerable temperature. The structure changed from ZSM-5 zeolite to SiO2-Al2O3 glass at 1240(degrees)C, and finally to SiO2-based cristobalite ceramics above 1275(degrees)C. A low dielectric constant (2.63-2.78) combined with low dielectric loss (< 0.0005 at 18 GHz) and small temperature coefficient of resonant frequency (varied from -18.6 to -8.1 ppm/C-degrees) was achieved in the present materials, and the value of dielectric loss was the lowest one achieved so far in the dielectric materials with a dielectric constant lower than 3. With the structure evolution from ZSM-5 zeolite to SiO2-Al2O3 glass and finally to SiO2-based cristobalite ceramics, the dielectric constant increased from 2.27 to 2.78, while the Qf value indicated a complicated variation tendency, and the higher Qf values were achieved in the amorphous and crystalline states, while significant drop was determined in the partial amorphous state. It should be a great challenge to prepare dense zeolite ceramics without collapse of ordered porous structure, and then the ultra-low dielectric constant materials with high Q could be expected.

Preparation and Dielectric Properties of Low Permittivity Fused Silica Ceramics

Crystal Structure, Infrared Reflectivity Spectra and Microwave Dielectric Properties of CaAl2O4 Ceramics with Low Permittivity

Crystal Structure, Vibrational Spectroscopy, and Microwave Dielectric Properties of CaAl4O7 Ceramics with Low Permittivity

Microwave Dielectric Properties Of Fused Silica Prepared By Different Approaches

Low-fired Fluoride Microwave Dielectric Ceramics with Low Dielectric Loss

Ultra-low permittivity ULTCC composite materials

Mechanical and Dielectric Properties of Porous Si3n4-Sio2 Composite Ceramics

Microstructure, mechanical and high-temperature dielectric properties of zirconia-reinforced fused silica ceramics

Mechanical and dielectric properties of porous Si3N4 ceramics prepared by modified water‐based gel casting

In-situ Reaction Synthesis of Porous Si2N2O-Si3N4 Multiphase Ceramics with Low Dielectric Constant Via Silica Poly-Hollow Microspheres

The study on fabrication of dielectric materials for low temperature Co-fired ceramics

Preparation of the LTCC Composite Ceramics with Low Permittivity

Dielectric Properties in GHz Range of Porous Si3N4–BN–SiO2 Ceramics with Considerable Flexural Strength Prepared by Low Temperature Sintering in Air

LiYGeO4: Novel Low-Permittivity Microwave Dielectric Ceramics with Intrinsic Low Sintering Temperature

High Dielectric Properties Of Low-Temperature Sintered (Ca0.5cu05)Tio3 Ceramics

Low‐temperature Sintering and Thermal Stability of Li2GeO3‐based Microwave Dielectric Ceramics with Low Permittivity

HIGH DIELECTRIC PROPERTIES OF LOW-TEMPERATURE SINTERED (Ca0.5Cu0.5)TiO3 CERAMICS

Rapid Preparation of Si3N4 Ceramics with High Thermal Conductivity and Low Dielectric Loss by Fast Hot-Pressing (FHP) Sintering

Sintering characteristics and crystallization for sol–gel-derived powders for low-dielectric and low-temperature sintering ceramics

Low‐k Dielectric Materials Derived from ZSM‐5 Zeolite

Preparation of Low Temperature Cofired CaO-MgO-SiO2 Microwave Ceramics Doped with Additives by Sol-Gel Method