Abstract:Due to their special appearance, spherical α‐Al2O3 nanoparticles play an important role for obtaining high performance structural and functional ceramics. However, there are still problems such as easily agglomerates to form worm‐like structures at high temperatures and difficult availability of spherical nanoparticles. In this study, spherical α‐Al2O3 nanoparticles with high dispersion were prepared by combination of microwave hydrothermal method and addition of nano‐Al particles as seeds. Firstly, spherical amorphous alumina precursors were synthetized by microwave hydrothermal method at 100°C for 30 min using Al2(SO4)3∙18H2O, Al(NO3)3∙9H2O and urea as raw materials, and then, spherical α‐Al2O3 nanoparticles with diameter of about 66 nm were acquired after calcined the precursor at 1050°C for 90 min by adding nano‐Al seeds, which reduced the calcination temperature by 50°C and holding time by 30 min compared to that without seeds. Kinetic analysis shows that 5 wt.% nano‐Al seeds can reduce the activation energy of crystalline transition of γ‐Al2O3 to α‐Al2O3 from 516.51 kJ/mol to 474.37 kJ/mol. Moreover, the microscopic mechanism of nano‐Al particles as seeds was investigated. The characterizations of sintering properties show that spherical α‐Al2O3 nanoparticles facilitate the acquisition of uniform microstructure for resulting ceramic and the fracture modes include both intergranular and transgranular fracture.This article is protected by copyright. All rights reserved

Preparation by Microwave Irradiation of Nanometre-Sized AlPO4-5 Molecular Sieve

Microwave preparation of molecular sieve AlPO4-5 with nanometer sizes

Synthesis and crystal morphology control of AlPO4-5 molecular sieves by microwave irradiation

Ultrafast synthesis of discrete submicron AlPO4-LTA molecular sieve crystals and their application in molecular sieve membrane

Studies on preparing molecular sieves AIPO4-5 and AIPO4-11 by the vapour phase method

Synthesis of the Molecular-Sieve Alpo4-5 with an Unequal Molar Ratio of Al2o3 to P2o5

Ionothermal Synthesis of Hierarchical Structured CuAPO-5 Molecular Sieve

Multinuclear solid-state NMR studies on the formation mechanism of aluminophosphate molecular sieves in ionic liquids

Molecular engineering of microporous crystals: (III) The influence of water content on the crystallization of microporous aluminophosphate AlPO4-11

Preparation of zeolite A membranes by microwave heating

Preparation of Nano-Kaolinite by Microwave-Assisted Chemical Reaction

Microwave synthesis process for ZSM-11 molecular sieve

Preparation of spherical α‐Al 2 O 3 nanoparticles by microwave hydrothermal synthesis and addition of nano‐Al seeds

STUDY ON SYNTHESIS OF MESOPOROUS MOLECULAR SIEVE MCM-41 Ⅱ. Microwave Synthesis Method

Stability and characterization of mesoporous molecular sieve using natural clay as a raw material obtained by microwave irradiation

Ionothermal Synthesis Process for Aluminophosphate Molecular Sieves in the Mixed Water/ionic Liquid System

Vapor Phase Transport Synthesis and Structure Characterization of an Aluminophosphate Molecular Sieve [Al3P3O12F][C5H5NH]center dot 0.2H(2)O

Molecular engineering of microporous crystals: (IV) Crystallization process of microporous aluminophosphate AlPO 4-11

Preparation and Characterization of Single Crystals of MAPO-43 Molecular Sieve

Microemulsion-based Solvothermal Synthesis of Aluminium Orthophosphate Nanocrystals

Microwave-assisted hydrothermal synthesis of nanozeolites with controllable size