Abstract:A novel wet-chemistry reaction-adsorption strategy via the facile acid-base interaction under mild conditions is demonstrated to fabricate the state-of-the-art Ru-Zn-La/ZrO2 catalysts for selective hydrogenation of benzene to cyclohexene. The catalyst preparation process is systematically investigated and verified with the combination of various characterization techniques. Preloading of lanthanide salts and alkali treatment after calcination not only favor the introduction of ruthenium and zinc species in the later stages but also help enhance the dispersion of the catalysts. The reaction rate constants (k1 and k2) decrease with the increment of the Zn/Ru molar ratio, and the selectivity at 40% conversion (S40) is positively correlated with the k1/k2 ratio, demonstrating the role of Zn species in retarding the hydrogenation activity of Ru and improvement of the selectivity to cyclohexene. In general, the catalytic behavior is dependent on the particle size of Ru, the La-to-Ru electron transfer effect, the content of Zn species, and the surface hydrophilicity of catalyst. These factors are generated by using different precursors and various predesigned La/Ru molar ratios in the preparation recipe. Moreover, a passivation treatment before the hydrogenation reaction can promote the cyclohexene selectivity of the catalyst Ru-Zn-La/ZrO2 (1.6 La/Ru) to 80.6% at a benzene conversion of 43.7%, which meets the industrial requirement. Notably, the specific activity of the catalyst is as high as 1224 gBZ center dot gRu-1 center dot h-1, over 10 times higher than the industrial criterion. This work provides new insights into the design of Ru-based catalysts for benzene hydrogenation and other hydrogenation reactions as well.

Liquid-Phase Partial Hydrogenation of Benzene over Ru/MgAl2O4 Catalyst: Effect of Calcination Temperature of MgAl2O4

Liquid-phase Hydrogenation of 2,2,4,4-Tetramethyl-1,3-cyclobutanedione over Supported Ru Based Catalysts

Synthesis of m-phenylenediamine from m-dinitrobenzene over silica-supported nickel catalyst

Influence of pretreatment temperature on catalytic performance of rutile TiO 2 -supported ruthenium catalyst in CO 2 methanation

CO2 Methanation over TiO2–Al2O3 Binary Oxides Supported Ru Catalysts

Preparation, characterization of Ru/AlOOH catalyst and its benzene partial hydrogenation behavior

Selective Hydrogenation of Benzene to Cyclohexene over Ru–Zn/ZrO2 Catalysts Prepared by a Two-Step Impregnation Method

Ru-Zn Catalysts for Selective Hydrogenation of Benzene Using Coprecipitation in Low Alkalinity

Colloidal RuB/Al2O3·xH2O Catalyst for Liquid Phase Hydrogenation of Benzene to Cyclohexene

Partial Hydrogenation of Benzene to Cyclohexene over Novel Ru-B/Mof Catalysts

Structural and Catalytic Properties of Alkaline Post‐Treated Ru/ZrO2 Catalysts for Partial Hydrogenation of Benzene to Cyclohexene

Hydrocracking of Bio-Alkanes over Pt/Al-MCM-41 Mesoporous Molecular Sieves for Bio-Jet Fuel Production

Influence Factors on Activity of Ru–Zn Catalysts in Selective Hydrogenation of Benzene

Hydrogenation of Methyl Benzoate to Benzaldehyde over Manganese Oxide Catalysts Prepared from Mg/Mn/Al Hydrotalcite-Like Compounds

Novel Reaction-Adsorption Method for Preparation of Ru-Zn-La/ZrO<sub>2</sub> Catalysts with High Catalytic Performance for Selective Hydrogenation of Benzene

M−Mn−Al Hydrotalcite-like Compounds As Precursors for Methyl Benzoate Hydrogenation Catalysts

Study on Ru-B/MIL-53(AlxCr1) Catalysts for Partial Hydrogenation of Benzene to Cyclohexene

Effect of Support Acidity on Liquid-Phase Hydrogenation of Benzene to Cyclohexene over Ru–B/ZrO2Catalysts

Influence of the Calcination on the Activity and Stability of the Cu/ZnO/Al2O3 Catalyst in Liquid Phase Methanol Synthesis

Effect of calcination temperature on catalytic properties of Ru-Co-ZrO2/γ-Al2O3 catalysts for Ficher-Tropsch synthesis

Catalytic hydrogenation of aromatic ring over ruthenium nanoparticles supported on α-Al2O3 at room temperature