Abstract:This article addresses the calculation of diffusion coefficients of CO 2 gas through PE-RT from continuous sweep permeation tests after different run times. Knowing the permeability and diffusion coefficients allows the solubility and concentration in the polymer film to be calculated. Other permeation methods used more often in engineering applications such as the closed cell manometric method traditionally provide estimates of the lag time diffusion coefficient often after just hours of first exposure. In Raheem et al. the potential for inferring alterations in morphology from the diffusion and permeability coefficients was raised. The previous study (Raheem et al., 2022) [1], covered analysis of permeation, diffusion and solubility coefficients, activation energies and crystallinity alterations to infer ageing attributes in polymers exposed to gaseous and supercritical CO 2 and H 2 . The lag-time method of calculation of the diffusion coefficient was applied when steady-state was reached. This study investigates methods such as those fitting the transients like the Taylor expansion, inflection of the first derivative of the flux, and variations in the calculations of the diffusion coefficient using chosen times in the flux curve (e.g., time-lag, half-point flux, Yen Shih method and similar fits). These can be implemented at various stages in the development of the permeation trace over several weeks. The time-lag method was compared to the other published methods to verify its effectiveness as a convenient technique for engineers to accurately estimate single gas diffusion in polymer films. It was found that the time-lag method ranged in agreement with the other published methods from less than 1% to up to 27%. The approaches presented support the study of transport coefficients employed for detecting alterations in polymeric structures. Consequentially, l iterature validation of the feasibility of detecting alterations in material structure, i.e., physical ageing through the monitor of the diffusion coefficient is reported in this communication.

Permeation time lag in polymeric hollow fiber membranes

A novel transport model for sorption and desorption of penetrants in dense polymeric membranes

Prediction of Solvent Solubility, Diffusivity and Permeability in Glassy Polymeric Membranes

Transient Diffusion in Bi-Layer Composites With Mass Transfer Resistance: Exact Solution and Time Lag Analysis

Design methodology of polymeric materials for membrane separationbased-on thermodynamic simulation

Experimental And Numerical Analyses On The Poly(Lactide-Co-Glycolide) Hollow Fiber Membranes

Permeation of Compressed and Supercritical Fluids Through Porous Membranes

A new model on the diffusion of small molecule penetrants in dense polymer membranes

Comparative Study of Polymer of Intrinsic Microporosity-Derivative Polymers in Pervaporation and Water Vapor Permeance Applications

Physicochemical Characteristics of Hollow Fiber Structured Packings in Isopropanol/Water Distillation

Permeation behaviors consistency in polymeric homogenous dense membranes

Effect of Molecular Association on Solubility, Diffusion, and Permeability in Polymeric Membranes

A Modified Solution–Diffusion Model and Its Application in the Pervaporation Separation of Benzene/Cyclohexane Mixtures in PDMS Membrane

Gas Transport in Mixed Matrix Membranes: Two Methods for Time Lag Determination

Experimental Velocity Measurements and Effect of Flow Maldistribution on Predicted Permeator Performances

An experimental and modeling investigation of the behaviors of solution in fluoropolymers hollow fiber membranes (HFMs)

A comparison of calculation methods for the diffusion coefficient as a potential tool for identifying material alteration with time

Performance Control of Asymmetric Poly(phthalazinone Ether Sulfone Ketone) Ultrafiltration Membrane Using Gelation

Dynamic Sorption and Anomalous Diffusion of Small Molecules in Dense Polyimide Membranes

Non-equilibrium Molecular Dynamics Simulation on Pure Gas Permeability Through Carbon Membranes

Coupled Diffusion of Water and Ethanol in a Polyimide Membrane