Abstract:Cordierite glass-ceramics usually begin to crystallize from the surface. As an efficient nucleating agent, TiO2 can promote the rapid transformation of glass to bulk crystallization, but it is easy to cause the increase of dielectric constant and light absorption. High crystallinity cordierite glass-ceramics were prepared by optimizing the heat treatment process without or with different nucleating agents in stoichiometric cordierite glasses. The results show that the crystallization mechanisms of glasses without and with ZrO2+P2O5 as nucleation agents are controlled by surface crystallization. While, the glass with TiO2+ZrO2+P2O5 as nucleation agents have the tendency to be bulk crystallization. The studied glasses are crystallized from surface and have different crystallization orientations with the inner glass. The thickness of crystalline layer increased with the increasing of heating temperatures, but the "surface-center" crystallization process cannot complete by further increasing heating temperatures because of softening deformation of glasses. At 1020 ℃, the glasses complete the "surface-center" crystallization for long durations. The glasses without nucleation agents and with ZrO2+P2O5 require 10 h, but the glass with TiO2+ZrO2+P2O5 complete for 5 h. Although all the three glasses complete the "surface-center" crystallization, the glasses with nucleation agents show the higher crystallinity upon the same heat treatments. Finally, glass-ceramics with excellent performance were obtained, for example, the Z1# glass-ceramic have the high microhardness ∼7.4 GPa, low thermal expansion coefficient ∼1.4☓10−6 ℃-1 at 20–300 ℃, and relatively high thermal conductivity ∼2.4 W/mK. It also exhibits low dielectric constant and loss, which was ∼4.5 and ∼1.2☓10-3 at 1 MHz, ∼ 4.9 and 2.3☓10-3 at 10.5 GHz..

Two Types of Phase Separation and Crystal Nucleation-Growth Mechanisms for Machinable Glass Ceramic

Kinetics of Phase Separation of Soda-Lime-silica Glass with Minor P2O5 Additions

EFFECT OF SPECIAL PHASE SEPARATION ON MICROSTRUCTURE AND PROPERTY OF GLASS-CERAMICS

Microstructure and crystallization behavior of glasses in the ZrO 2-ZnO-Al2O3-SiO2 system

Microstructure and Crystallization Behavior of Glasses in the ZrO2-ZnO-Al2O3-SiO2 System

Relationship Between the Phase Separation and Crystallization of Bioglass-Ceramic in Na 2 O-B 2 O 3 -Sio 2 -Cao-p 2 O 5 -F System

Modeling Phase Separation Mechanisms in Oxy‐fluoride Glass‐ceramics Containing SrF2:Ln3+ and ZnAl2O4:Cr3+ Nanocrystals

From Phase Separation to Nanocrystallization in Fluorosilicate Glasses: Structural Design of Highly Luminescent Glass-Ceramics

Phase Separation And Crystallization Of Li2o Center Dot Al2o3 Center Dot 4sio(2)-Ta2o5 Glass-Ceramics

Phase separation in mullite-composition glass

Study on isothermal crystallization kinetics of mica glass ceramics

Phase Separation Inducing Controlled Crystallization of Gese2-Ga2se3-Csi Glasses for Fabricating Infrared Transmitting Glass-Ceramics

Study on Phase Separation and Crystallization of Na2O-B2O3-SiO2-TiO2 Glass

Phase separation and crystallization of Li 2O · Al 2O 3 · 4SiO 2-Ta 2O 5 glass-ceramics

Non-isothermal Crystallization Kinetics and Phase Transformation of Bi2O3-SiO2 Glass-Ceramics

In Situ High-Temperature Crystallographic Evolution of a Nonstoichiometric Li2O·2SiO2 Glass

Synthesis and crystallization kinetics of Y2CaAl4SiO12 garnet-type glass-ceramic

Effects of particle size on the crystallization kinetics characterization in CaO–SiO2‐based glass, Part 2: In complex crystallization processes with two or more crystal phases

Crystallization mechanisms of cordierite glass-ceramics with “surface-center” crystallization behavior

Insight into the structure and crystallization of SiO2-Al2O3-P2O5-Na2O-MgO-CaO glass system with Mg-Ca substitution: A molecular dynamics study

The crystallization and microstructure evolution of lithium disilicate-based glass-ceramic