Abstract:In the present paper, the forced convection heat transfer characteristics of water in a vertically upward internally ribbed tube at supercritical pressures were investigated experimentally. The six-head internally ribbed tube is made of SA-213T12 steel with an outer diameter of 31.8mm and a wall thickness of 6mm and the mean inside diameter of the tube is measured to be 17.6mm. The experimental parameters were as follows. The pressure at the inlet of the test section varied from 25.0 to 29.0MPa, and the mass flux was from 800 to 1200kg/(m2s), and the inside wall heat flux ranged from 260 to 660kW/m2. According to experimental data, the effects of heat flux and pressure on heat transfer of supercritical pressure water in the vertically upward internally ribbed tube were analyzed, and the characteristics and mechanisms of heat transfer enhancement, and also that of heat transfer deterioration, were also discussed in the so-called large specific heat region. The drastic changes in thermophysical properties near the pseudocritical points, especially the sudden rise in the specific heat of water at supercritical pressures, may result in the occurrence of the heat transfer enhancement, while the covering of the heat transfer surface by fluids lighter and hotter than the bulk fluid makes the heat transfer deteriorated eventually and explains how this lighter fluid layer forms. It was found that the heat transfer characteristics of water at supercritical pressures were greatly different from the single-phase convection heat transfer at subcritical pressures. There are three heat transfer modes of water at supercritical pressures: (1) normal heat transfer, (2) deteriorated heat transfer with low HTC but high wall temperatures in comparison to the normal heat transfer, and (3) enhanced heat transfer with high HTC and low wall temperatures in comparison to the normal heat transfer. It was also found that the heat transfer deterioration at supercritical pressures was similar to the DNB at subcritical pressures.

Study of the Thermophysical Characteristics of a Supercritical Fluid at the Quasi-critical Point Based on the Ray Method

Experimental Study of the γ-ray Method for Measuring the Gas Content in a Cross Section with a Subcritical Steam-water Two-phase Flow

Investigation on Characteristics of Experiment about Single-Beam Measurements of Supercritical Fluid

Experimental Investigation On Heat Transfer And Frictional Characteristics Of Vertical Upward Rifled Tube In The Advanced Ultra Supercritical Steam Generator

Comprehensive evaluation on the thermal-hydraulic performance of supercritical CO2/R41 in a micro-fin tube

Numerical Studies of Supercritical Turbulent Convective Heat Transfer of Cryogenic-Propellant Methane

Experimental Study of the Heat Transfer Characteristics of Supercritical Pressure R134a in a Horizontal Tube

Buoyancy Effects on Supercritical-Pressure Conjugate Heat Transfer of Aviation Kerosene in Horizontal Tubes

Experimental Study of Heat Transfer Characteristics Under Supercritical Pressure of Upwards Inclined Rifled Tubes

Study of the Characteristics of an Annular Flow Liquid Film and Disturbance Waves in a Vertical Riser by Using Gamma Rays

Numerical Study of Flow and Heat Transfer of Supercritical Water in Rifled Tubes Heated by One Side

Experimental Research on Wall Temperature Distribution and Heat Transfer Characteristics of the Tilted Smooth Riser Tubes in the Supercritical Pressure Region

Heat Transfer Characteristics of Supercritical Pressure Water in Vertical Upward Rifled Tube

A New Method on Fluid-to-fluid Scaling for Heat Transfer in Tubes at Supercritical Pressures

Investigation And Modeling Of The In-Tube Heat Transfer Of Fluids At Supercritical Pressure During Heating

Investigation of forced convection heat transfer of supercritical pressure water in a vertically upward internally ribbed tube

Investigation on Heat Transfer Characteristics of Ultra-Supercritical Water in Vertical Upward Internally Ribbed Tube

An Investigation on Heat Transfer to Supercritical Water in Inclined Upward Smooth Tubes

Experimental investigation on heat transfer characteristics of low mass﹣flux rifled tube for supercritical pressure boiler with annular furnace

Numerical Investigation of Heat Transfer Characteristics of scCO2 Flowing in a Vertically-Upward Tube with High Mass Flux

Evaluation Criterion of Buoyancy and Thermal Acceleration Behavior of Supercritical CO; in a Horizontal Circle Tube