Abstract:Magnesium salts are commonly employed as ammonium-free leaching agents in the extraction of weathered crust elution-deposited rare earth ores (WCE-REO). Nonetheless, these salts frequently face technical challenges, including relatively low leaching rates and inadequate permeability in the in-situ leaching process. In this study, cetyltrimethylammonium chloride (CTAC) was used as a novel leaching aid agent to improve the rare earth leaching process. The effects of CTAC and pH on the rare earth leaching behavior and permeability was investigated. The leaching kinetic model was established and the regulation mechanism by which CTAC interacts with clay mineral surfaces was revealed for rare earth leaching process enhanced by CTAC. The results indicate that the appropriate amount of CTAC can increase the permeation velocity by 1.16×10 −4 cm·s −1 . Moreover, the rare earth leaching rate increased from 83.75 % to 95.65 %, accompanied by a reduction in leaching equilibrium time under optimal conditions. However, a higher concentration of CTAC results in a lower permeation velocity due to the increasing viscosity and the hydrophilicity. The relatively low pH will affect permeability of composite leaching agent in the ore pillar, diminishing its beneficial impact on rare earth leaching. The kinetic equation, fitted by the shrinking core model, suggests that the leaching adheres to an internal diffusion control mechanism, underscoring mass transfer as the pivotal limiting factor in rare earth leaching. CTAC reduces surface tension and viscosity, facilitating the permeation of the leaching solution into the rare earth ore. Furthermore, CTAC can be adsorbed on the surface of rare earth mineral particles, increasing the contact angle of clay minerals, elevating the Zeta potential, and diminishing the thickness of the diffusion layer, thus promoting mass transfer during leaching. The results of atomic force microscopy (AFM) analysis shows that the appropriate amount of CTAC adsorbed on rare earth ores can decreases the thickness of the hydration film on the particles' surface, further improving the mass transfer efficiency during the leaching process. The findings of this study offer new insights into the green and efficient extraction of rare earth resources from both theoretical and technical perspectives.

Experiment on selecting leach agent for extracting sc from rare earth containing sc

Experimental Study on Concentrating Scandium by Leaching from Associated Scandium Ore

Experimental study on extraction of scandium from hydrochloride acid leaching liquid in TBP

Selection of the extractants for available rare earths in soils

Experimental study on extraction of scandium from complex silicate ore

Experimental Investigation On Media Condition Of Leaching Scandium From Silt Of Yangtze

Extraction of Scandium from Ion-Adsorptive Rare Earth Deposit by Naphthenic Acid

Enhanced extraction of scandium and inhibiting of iron from acid leaching solution of red mud by D2EHPA and sodium chloride

Study on Scandium Separation from Rare Earth Ore in Yunnan Province

Experimental Study of Pre-concentration from Silicate Containing Rare Earth Ore with Scandium by Magnetic Separation

Extraction of Scandium and Iron from Red Mud

Efficient Selective Extraction of Scandium from Red Mud

Effect of Leaching Conditions on Leaching Rate of Rare Earth and Iron

High-Selective Extraction of Scandium (Sc) from Bauxite Residue (Red Mud) by Acid Leaching with MgSO4

Assessing the Efficiency of Ion Exchange Resins for the Recovery of Scandium from Sulfuric Acid Leaching Solutions

Selective Recovery of Scandium (Sc) from Sulfate Solution of Bauxite Residue Leaching Using Puromet МТS9580 Ion-Exchange Sorption

Leaching process assisted by cetyltrimethylammonium chloride for weathered crust elution-deposited rare earth ores: Leaching behavior, kinetic analysis and interfacial regulation

Research on High-Pressure Hydrochloric Acid Leaching of Scandium, Aluminum and Other Valuable Components from the Non-Magnetic Tailings Obtained from Red Mud after Iron Removal

Selective recovery of vanadium and scandium by ion exchange with D201 and solvent extraction using P507 from hydrochloric acid leaching solution of red mud

STUDY ON APPLICATION OF MAGNETIC SEPARATION IN EXTRACTING SC FROM RARE EARTH ORE

Recovery of rare earth elements from sedimentary rare earth ore via sulfuric acid roasting and water leaching