Abstract:Anaerobic digestion (AD) produces useful biogas and waste streams with high levels of dissolved methane (CH4) and ammonium (NH4+), among other nutrients. Membrane biofilm reactors (MBfRs), which support dissolved methane oxidation in the same reactor as simultaneous nitrification and denitrification (ME-SND), are a potential bubble-less treatment method. Here, we demonstrate ME-SND taking place in single-stage, AD digestate liquid-fed MBfRs, where oxygen (O2) and supplemental CH4 were delivered via pressurized membranes. The effects of two O2 pressures, leading to different O2 fluxes, on CH4 and N removal were examined. MBfRs achieved up to 98% and 67% CH4 and N removal efficiencies, respectively. The maximum N removal rates ranged from 57 to 94 mg N L-1 d-1, with higher overall rates observed in reactors with lower O2 pressures. The higher-O2-flux condition showed NO2- as a partial nitrification endpoint, with a lower total N removal rate due to low N2 gas production compared to lower-O2-pressure reactors, which favored complete nitrification and denitrification. Membrane biofilm 16S rRNA amplicon sequencing showed an abundance of aerobic methanotrophs (especially Methylobacter, Methylomonas, and Methylotenera) and enrichment of nitrifiers (especially Nitrosomonas and Nitrospira) and anammox bacteria (especially Ca. Annamoxoglobus and Ca. Brocadia) in high-O2 and low-O2 reactors, respectively. Supplementation of the influent with nitrite supported evidence that anammox bacteria in the low-O2 condition were nitrite-limited. This work highlights coupling of aerobic methanotrophy and nitrogen removal in AD digestate-fed reactors, demonstrating the potential application of ME-SND in MBfRs for the treatment of AD's residual liquids and wastewater. Sensor-based tuning of membrane O2 pressure holds promise for the optimization of bubble-less treatment of excess CH4 and NH4+ in wastewater.

Intermittently aerated EMMC-Biobarrel (entrapped mixed microbial cell with Bio-barrel) process for concurrent organic and nitrogen removal

Entrapped mixed microbial cell process for combined secondary and tertiary wastewater treatment.

Performance and microbial communities of different biofilm membrane bioreactors with pre-anoxic tanks treating mariculture wastewater

Simultaneous Ammonia and Nitrate Removal in an Airlift Reactor Using Poly(butylene Succinate) As Carbon Source and Biofilm Carrier.

Removal of organic and nitrogen and molecular weight distribution of residual soluble organic from entrapped mixed microbial cells and activated sludge processes.

Biocarriers Facilitated Gravity-Driven Membrane (GDM) Reactor for Wastewater Reclamation: Effect of Intermittent Aeration Cycle.

Enhancement of Nitrogen Removal in an Intermittent Aeration Membrane Bioreactor

Simultaneous Effective Carbon and Nitrogen Removals and Phosphorus Recovery in an Intermittently Aerated Membrane Bioreactor Integrated System

An Innovative Membrane Bioreactor (MBR) System for Simultaneous Nitrogen and Phosphorus Removal

Evaluation of Direct Removal of Nitrate with Entrapped Mixed Microbial Cell Technology Using Ethanol As the Carbon Source

A Membrane Bioreactor for an Innovative Biological Nitrogen Removal Process.

Evaluation of performance and carbon reduction of intermittent aeration membrane bioreactor

Simultaneous carbon and nitrogen removals in membrane bioreactor with mesh filter: An experimental and modeling approach

Simultaneous Removal of Organic Substances and Nitrogen Using Amembrane Bioreactor Seeded with Anaerobic Granular Sludge under Oxygen-Limited Conditions

Treatment of Anaerobic Digester Liquids via Membrane Biofilm Reactors: Simultaneous Aerobic Methanotrophy and Nitrogen Removal

Enhanced Methanogenic Degradation and Membrane Fouling Associated with Protein-Eps by Extending Sludge Retention Time in a High-Solid Anaerobic Membrane Bioreactor Treating Concentrated Organic Sludge.

Membrane Bioreactor Vs. Oxidation Ditch: Full-Scale Long-Term Performance Related with Mixed Liquor Seasonal Characteristics

Nitrogen and Carbon Removals from Food Processing Wastewater by an Anoxic/aerobic Membrane Bioreactor

Enhancement of Organic Matter Removal in an Integrated Biofilm-Membrane Bioreactor Treating High-Salinity Wastewater

Membrane Contamination Control in the Intermittent Aeration Mode of Operation of the C-MBR Process for Campus Wastewater Reuse

Process characteristics and energy self-sufficient operation of a low-fouling anaerobic dynamic membrane bioreactor for up-concentrated municipal wastewater treatment