Abstract:Saturated flow boiling experiments were conducted to investigate the influence of surface wettability on the hydraulic and thermal transport performance in a large width-to-height aspect ratio, one-sided heated rectangular microchannel with deionized water as the working fluid. The contact angles of the bare silicon wafer surface and superhydrophilic surface after deposited by a thin film of 100-nm-thickness silicon dioxide were 65 3 and less than 5 respectively, both of which were utilized as heated surfaces of the microchannel. Parametric experimental studies were carried out with the inlet vapor quality varied from 0.03 to 0.1 and the wall heat fluxes spanned from 4 W/cm(2) to 20 W/cm(2), at various mass fluxes ranging from 120 to 360 kg/m(2) s. High speed flow visualizations were conducted coupled with instrumental measurements to illustrate the effects of heat flux, mass flux and two phase inlet quality on the local heat transfer coefficient, averaged heat transfer performance, two phase flow structure and pressure drop characteristics for surfaces with distinct surface wettability characteristics in the microchannel. Experimental results showed that the local heat transfer coefficient decreased first until approaching a minimum value and then increased towards the exit along the flow direction. Severe heat transfer deterioration was obtained for the bared silicon wafer surface with increased inlet vapor quality and heat flux, resulting from the local dryout phenomenon as can be verified by the flow visualization. While the heat transfer performance of the superhydrophilic surface was relatively constant due to continuous and uniform distribution of the thin liquid film on the heated surface during annular flow dominance and subsequent delay to partial dryout occurrence, which outperformed the untreated hydrophilic surface without additional pressure drop penalty. (C) 2017 Elsevier Ltd. All rights reserved.

An experimental study of convective heat transfer in silicon microchannels with different surface conditions

Detailed Heat Transfer Measurements of Curved Fin Channels

Experimental Investigation of Water Flow in Smooth and Rough Silicon Microchannels

HEAT TRANSFER CHARACTERISTICS OF WATER FLOWING THROUGH MICROCHANNELS

Flow Characteristics in A Trapezoidal Silicon Microchannel

Experimental Study of Single-Phase Pressure Drop and Heat Transfer in a Micro-Fin Tube

Numerical investigation on slip-flow and heat transfer characteristics in the entrance region of elliptical microchannels

Numerical simulation study of thermal and hydraulic characteristics of laminar flow in microchannel heat sink with water droplet cavities and different rib columns

Local Heat Transfer of Saturated Flow Boiling in Vertical Narrow Microchannel

Effects of Heat Flux, Mass Flux and Two-Phase Inlet Quality on Flow Boiling in a Vertical Superhydrophilic Microchannel

Experimental Study Of Saturated Flow Boiling In Vertical Narrow Microchannel

Pressure Drop and Flow Boiling Instabilities in Silicon Microchannel Heat Sinks

Nucleate Boiling Heat Transfer in Silicon-Based Micro-Channels

Forced Heat Convection of Wavy Fin Channel

Effects of geometric parameters on fluid flow and heat transfer in microchannel heat sink with trapezoidal grooves in sidewalls

Numerical study of entropy generation and forced convection heat transfer of a nanofluid in a channel with different fin cross-sections

Experimental Study and Mechanism Analysis of the Flow Boiling and Heat Transfer Characteristics in Microchannels with Different Surface Wettability

Numerical investigations of heat transfer augmentation in a microchannel heat sink with different shaped periodic reentrant cavities on channel sidewalls

Flow Boiling in Vertical Narrow Microchannels of Different Surface Wettability Characteristics

Simultaneously developing flow and heat transfer in circular and parallel-plates microchannels with velocity slip and temperature jump

Influences of geometrical parameters on the heat transfer characteristics through symmetry trapezoidal-corrugated channel using SiO2-water nanofluid