Abstract:A series of HZSM-5 zeolites modified with various mass fractions of antimony oxide Sb2O3(0-30%) were prepared by solid state ion exchange method,and then physically mixed with an industrial methanol synthesis catalyst(XNC-98) to form a series of hybrid catalysts CuO-ZnO-Al2O3+Sb2O3/HZSM-5.The direct synthesis of dimethyl ether(DME) from syngas was carried out over the prepared hybrid catalysts under pressurized fixed-bed continuous flow conditions.The results indicated that over the CuO-ZnO-Al2O3+Sb2O3/HZSM-5 hybrid catalysts with suitable amount of Sb2O3 the selectivities of undesired byproducts hydrocarbons and CO2 were significantly decreased from 9.3% and 32.4% to less than 1% and 28%,respectively,and the selectivity for DME was enhanced greatly from 55% to 69% under temperature of 260℃,pressure of 4 MPa and gas hourly space velocity of 1500 ml/(g·h),compared with that over the unmodified HZSM-5 hybrid catalysts.It was clear from the results of NH3-TPD characterization that the decrease in the formation of hydrocarbons and CO2 could be attributed to the significant decline in the amount of strong acid sites induced by Sb2O3 modification.In addition,the influences of the operating parameters,including the reaction temperature,pressure and space velocity of feed on the catalytic performance of the hybrid catalysts were also investigated.It was shown that at high reaction temperature and high gas hourly space velocity both lower CO conversion and lower DME selectivity were obtained,the suitable reaction temperature and gas hourly space velocity would be less than 280℃ and 3000 ml/(g·h),respectively.

Highly Effective Conversion of Syngas to Dimethyl Ether over the Hybrid Catalysts Containing High-Silica HMCM-22 Zeolites

An Effective Catalyst for Syngas-To-Dimethyl Ether Process with Steamed Zeolite Hmcm-49 As Dehydration Component

One-Step Synthesis of Dimethyl Ether from Syngas with Fe-Modified Zeolite ZSM-5 as Dehydration Catalyst

Influence of SiO2/Al2O3 ratio in HMCM-22 on catalytic performance of Cu2ZnO2Al2O3/HMCM-22 for synthesis of dimethyl ether

THE DIRECT SYNTHESIS OF DIMETHYL ETHER FROM SYNGAS OVER THE HYBRID CATALYST WITH ANTIMONY MODIFIED HZSM-5 ZEOLITE AS ACID COMPONENT

Dimethyl Ether Synthesis from Methanol and Syngas over Different Sized HY Zeolite and Cu-Mn-Zn/HY Bifunctional Catalyst

Highly Efficient Synthesis of Dimethyl Ether from Syngas over the Admixed Catalyst of CuO–ZnO–Al2O3 and Antimony Oxide Modified HZSM-5 Zeolite

Influence of SiO_2/Al_2O_3 Ratio in HMCM-22 on Catalytic Performance of Cu-ZnO-Al_2O_3/HMCM-22 for Synthesis of Dimethyl Ether

Bifunctional catalysts based on PdZn/ZnO and hierarchical zeolites in the direct synthesis of dimethyl ether from CO-rich syngas: influence of the support and the Zn/Pd molar ratio

The Direct Synthesis of Dimethyl Ether from Syngas over Hybrid Catalysts with Sulfate-Modified Γ-Alumina As Methanol Dehydration Components

Effects of Ammonium Hexafluorosilicate Modification on Acidity of Hmcm-22 and Catalytic Performance of Cuo-Zno-Al2o3/Hmcm-22 for Dimethyl Ether Synthesis

Micro-mesoporous Composite Molecular Sieves H-ZSM-5/MCM-41 for Methanol Dehydration to Dimethyl Ether: Effect of SiO2/Al2O3 Ratio in H-ZSM-5

Single-Step Synthesis of Dimethyl Ether from Biomass-Derived Syngas over Cuo-Zno-Mox (M = Zr, Al, Cr, Ti)/Hzsm-5 Hybrid Catalyst: Effects of Mox

One-step synthesis of dimethyl ether from biomass-derived syngas on CuO-ZnO-Al2O3/HZSM-5 hybrid catalyst: Combination method, synergistic effect, water-gas shift reaction and catalytic performance

Effect of different ratios of Si-Al of zeolite HZSM-5 on the activity of bifunctional catalysts upon dimethyl ether synthesis

Dealumination of HMCM-22 by various methods and its application in one-step synthesis of dimethyl ether from syngas

Dimethyl Ether Synthesis Via Methanol and Syngas over Rare Earth Metals Modified Zeolite Y and Dual Cu–Mn–Zn Catalysts

Synergism Between the Lewis and Brönsted Acid Sites on HZSM-5 Zeolites in the Conversion of Methylcyclohexane

Effect of Si Content on the Performance of Direct Synthesis of Dimethyl Ether over Slurry CuZnAl Catalyst Prepared by Complete Liquid Phase Technology

Catalyst consisting of Ag nanoparticles anchored on amine-derivatized mesoporous silica nanospheres for the selective hydrogenation of dimethyl oxalate to methyl glycolate

Direct Conversion of Syngas into Methyl Acetate, Ethanol and Ethylene by Relay Catalysis via Dimethyl Ether Intermediate.