Abstract:The growth and structural properties of ZnO thin films on Zn atoms both Au(111) and Cu(111) surfaces were studied using either NO2 or O-2 as oxidizing agent. The results indicate that NO2 promotes the formation of well-ordered ZnO thin films on both Au(111) and Cu(111). The stoichiometric ZnO thin films obtained on these two surfaces exhibit a flattened and non-polar ZnO(0001) structure. It is shown that on Au(111), the growth of bilayer ZnO nanostructures (NSs) is favored during the deposition of Zn in presence of NO2 at 300 K, whereas both monolayer and bilayer ZnO NSs could be observed when Zn is deposited at elevated temperatures under a NO2 atmosphere. The growth of bilayer ZnO NSs is caused by the stronger interaction between two ZnO layers than between ZnO and Au(111) surface. In contrast, the growth of monolayer ZnO NSs involves a kinetically controlled process. ZnO thin films covering the Au(111) surface exhibits a multilayer thickness, which is consistent with the growth kinetics of ZnO NSs. Besides, the use of O-2 as oxidizing agent could lead to the formation of substoichiometric ZnOx structures. The growth of full layers of ZnO on Cu(111) has been a difficult task, mainly because of the interdiffusion of Zn promoted by the strong interaction between Cu and Zn and the formation of Cu surface oxides by the oxidation of Cu(111). We overcome this problem by using NO2 as oxidizing agent to form well-ordered ZnO thin films covering the Cu(111) surface. The surface of the well-ordered ZnO thin films on Cu(111) displays mainly a moire pattern, which suggests a (3 x 3) ZnO superlattice supported on a (4 x 4) supercell of Cu(111). The observation of this superstructure provides a direct experimental evidence for the recently proposed structural model of ZnO on Cu(111), which suggests that this superstructure exhibits the minimal strain. Our studies suggested that the surface structures of ZnO thin films could change depending on the oxidation level or the oxidant used. The oxidation of Cu(111) could also become a key factor for the growth of ZnO. When Cu(111) is pre-oxidized to form copper surface oxides, the growth mode of ZnOx is altered and single-site Zn could be confined into the lattice of copper surface oxides. Our studies show that the growth of ZnO is promoted by inhibiting the diffusion of Zn into metal substrates and preventing the formation of sub-stoichiometric ZnOx. In short, the use of an atomic oxygen source is advantageous to the growth of ZnO thin films on Au(111) and Cu(111) surfaces.

Epitaxial growth of ZnO films on thin FeO(111) layers

The growth of nanoscale ZnO films by pulsed-spray evaporation chemical vapor deposition and their structural, electric and optical properties

Structure and Properties of Fe 3 O 4 Films Grown on ZnO Template Via Metal Organic Chemical Vapor Deposition

Ordered ultra thin ZnO films on metal substrate

Low-temperature epitaxy of ZnO films on Si(0 0 1) and silica by reactive e-beam evaporation

Epitaxial growth of Fe3O4 thin films on ZnO and MgO substrates

Initial Oxidation and Interfacial Diffusion of Zn on Faceted MgO(111) Films.

Low-Temperature Epitaxy Of Zno Films On Si(001) And Silica By Reactive E-Beam Evaporation

Structural and Optical Characterizations of ZnO Films Grown by Reactive Electron Beam Evaporation

STRUCTURAL AND OPTICAL STUDIES OF ZnO FILMS GROWN AT LOW TEMPERATURE

High-Index Epitaxial Fe Films Grown on MgO(113)

Comparison of Structural and Optical Properties of ZnO Films Grown on Different Substrates at Low Temperatures

Growth of Ordered ZnO Structures on Au(111) and Cu(111)

THE Fe ULTRATHIN FILM ON ZnO(000-1) SURFACE: GROWTH, STRUCTURE, AND INTERACTION

Growth of Cubic MgxZn1-xO Films and Characterization

Epitaxial Deposition of Zn (0 0 2) for Stable Zinc Metal Anodes

Structural and electrical properties of (110) ZnO epitaxial thin films on (001) SrTiO3 substrates

Van der Waals Epitaxial Growth of ZnO Films on Mica Substrates in Low-Temperature Aqueous Solution

Growth of ZnO thin films on LSAT(111) substrates by plasma-assisted radio-frequency molecular beam epitaxy

Epitaxial Growth Of Zno On Gan/Sapphire Substrate By Radio-Frequency Magnetron Sputtering

Growth of high-quality ZnO thin films on (11\bar{2}0) a-plane sapphire substrates by plasma-assisted molecular beam epitaxy