Abstract:Nitrogen-rich ultra-thin (1-2 nm thick) layers in diamond produced by high-temperature nitrogen ion (N2+) implantation at low N2+ energies studied by in situ x-ray photoelectron spectroscopy are reported. Nitrogen bonding at the subsurface region and its thermal stability, as well as structural defects in polycrystalline diamond (PCD) implanted with 200, 500, and 800 eV N2+ at room temperature (RT) and 600 °C at an ion dose of 4.5 × 1014 ions/cm2, are investigated. Implantation at RT leads to nitrogen bonding at interstitial and substitutional sites in the diamond lattice, which is associated with the C-N/C=N bond, lower intensity of the C≡N (nitrile-like) component associated with nitrogen bonding with carbon defects, and quaternary nitrogen. The relative composition of these chemical states varies with implantation energy, temperature, and post-implantation annealing temperature. Upon annealing the RT implanted layers above 500-600 °C, the interstitial nitrogen converts to substitutional nitrogen. This process competes with nitrogen desorption. The thermal stability of nitrogen increases with implantation energy. Implantation at 600 °C at 800 eV resulted in a significantly lower concentration of nitrile-like bonds and a lower density of structural defects compared to RT implantation at the same energy. These effects are associated with dynamic annealing, which becomes more significant at higher implantation energies. Upon high-temperature implantation, nitrogen mostly populates directly substitutional sites. Nitrogen implantation at low energy and high temperature may be a viable way to nitride diamond surfaces with reduced density of defects where nitrogen is selectively bonded to substitutional sites. Finally, a comparison between nitrogen implantation into PCD and Diamond (100) [Di(100)] surfaces is presented.

Ion irradiation induced structural modifications in diamond nanoparticles

Ion implantation in nanodiamonds: size effect and energy dependence

Probing the Nanostructure of Neutron-Irradiated Diamond Using Raman Spectroscopy

Irradiation-induced Phase Transformations in Carbon Nanostructures

Spectral analysis of nanosize forms of carbon synthesized by pulsed intense ion beams

In-situ TEM observations of the structural stability in carbon nanotubes, nanodiamonds and carbon nano-onions under electron irradiation

Influence of Carbon Ion Energy on Properties of Highly Tetrahedral Diamond-Like Carbon

Characterization of nanocrystalline diamond films implanted with nitrogen ions

Effects Of High Energy Au-Ion Irradiation On The Microstructure Of Diamond Films

Subsurface nitrogen bonding, thermal stability, and retention of 200 eV N 2 + implanted polycrystalline diamond studied by in situ X-ray photoelectron spectroscopy

Structural, Raman and photoluminescence studies on nanocrystalline diamond films: Effects of ammonia in feedstock

Dynamic annealing assisted near-surface structural and bond stabilization in high-temperature low-energy N2+ implanted diamond

Radiation Damage Effects on Optical, Electrical, and Thermophysical Properties of CVD Diamond Films

Diamond-defect engineering of NV- centers using ion beam irradiation

Micro and nano-patterning of single-crystal diamond by swift heavy ion irradiation

Charge transfer effects, thermo- and photochromism in single crystal CVD synthetic diamond

Carbon Ion Irradiation Induced Structural, Optical and Electrical Effects in TiO2 Nanoparticles

Carbon Nanostructures Produced Through Ion Irradiation

Microstructure evolution and nanohardness of nanostructured TiAlN coating under N+ ion irradiation

Ion-irradiation-induced Structural Evolution in Ti4AlN3

Formation of C–N Compounds by N-implantation into Diamond Films