Abstract:This work studied the composition of Ni-Co-ZrO2/Al2O3 catalyst on properties and efficiency of catalysts for carbon dioxide reforming of methane (CMR) when CO2 was fed as the limiting reagent and CH4 as the excess reactant. 9wt%Ni-1wt%ZrO2/Al2O3, 4.5wt%Ni-4.5%wtCo-1wt%ZrO2/Al2O3, 9wt%Co-1wt%ZrO2/Al2O3 and 7wt%Co-3wt%ZrO2/Al2O3 catalysts were prepared by wet impregnation method. The physicochemical properties of present catalysts were characterized by XRD, N2 adsorption-desorption H2-TPR and CO2-TPD. The CRM performance was determined in a tubular fixed-bed reactor at 600 °C for 6 h with limiting of carbon dioxide. The carbon deposition on spent catalysts were examined by TGA. The results showed that Co-ZrO2 catalysts provided greater activities, selectivity toward H2 and stability than Ni-ZrO2 and Ni-Co-ZrO2 catalysts. 9wt%Co-1wt%ZrO2/Al2O3 provided higher reactant conversions and H2/CO ratio than 7wt%Co-3wt%ZrO2/Al2O3 while the minimum coke formation was observed on spent 7wt%Co-3wt%ZrO2/Al2O3. It is because oxophilic properties and oxygen vacancy sites in Co-ZrO2 increase CO2 dissociative adsorption as well as oxygen transport on the catalyst surface. HIGHLIGHTS This work developed Ni-Co-ZrO2/Al2O3 catalysts for carbon dioxide reforming of methane (CMR) when CO2 is fed as the limiting reagent demonstrated petroleum refinery application. Remarkable points of this work are revealed below. Co-ZrO2 catalysts provided greater reactant activities, selectivity toward H2 and stability than Ni-ZrO2 and Ni-Co-ZrO2 The oxophilic property accompanied with oxygen vacancy sites in Co-ZrO2 increase CO2 dissociative absorption and oxygen transport on the catalyst surface. 9wt%Co-1wt%ZrO2/Al2O3 provided relative highest reactant conversions and highest H2/CO ratio. 7wt%Co-3wt%ZrO2/Al2O3 presented the minimum coke formation. GRAPHICAL ABSTRACT

Supported Co Catalysts for Methane Reforming with CO2

Study Of Durable Catalyst For Methane Reforming Using Co2

Supported Cobalt Catalyst Promoted by Noble Metals for CH4/CO2 Reforming to SyngasⅠ.Preparation Conditions and Performance of Pt-Co/Al2O3 Catalyst

Reformation of methane with carbon dioxide to syngas: I. Catalytic performance of Co catalyst calcined at high temperature

Catalytic Performance and Characterization of Pt‐Co/Al2O3 Catalysts for CO2 Reforming of CH4 to Synthesis Gas

Meso-porous Ni/Mg/Al catalysts for methane reforming with CO2

Sensitivity of the properties and performance of Co catalyst to the nature of support for CO2 reforming of CH4

Investigation of CH 4 Reforming with CO 2 on Meso-Porous Al 2 O 3 -Supported Ni Catalyst

Investigation of CH<sub>4</sub> Reforming with CO<sub>2</sub> on Meso-Porous Al<sub>2</sub>O<sub>3</sub>-Supported Ni Catalyst

Characterization of Ca-promoted Ni/α-Al2O3 Catalyst for CH4 Reforming with CO2

Study of Partial Oxidation and CO2 Reforming of Methane on Co Based Catalysts

CO2 reforming of methane to synthesis gas over sol–gel-made Co/γ-Al2O3 catalysts from organometallic precursors

Small Amounts of Rh-Promoted Ni Catalysts for Methane Reforming with CO 2

The Influence of Reduction Temperature on the Performance of ZrOx/Ni-MnOx/SiO2 Catalyst for Low-Temperature CO2 Reforming of Methane

Carbon Deposition on Meso-Porous Al2o3 Supported Ni Catalysts in Methane Reforming with Co2

Carbon dioxide reforming of methane over a novel Ni/Al2O3 catalysts

Study of Ni-Co-ZrO2/Al2O3 Catalysts for Carbon Dioxide Reforming of Methane at Low CO2

Reforming of Methane with Oxygen and Carbon Dioxide to Produce Syngas over A Novel Pt/Coal2o4/Al2o3 Catalyst

Tailored Ni-MgO Catalysts: Unveiling Temperature-Driven Synergy in CH4-CO2 Reforming

Dry Reforming of Methane over CeO2-supported Pt-Co Catalysts with Enhanced Activity

Effects of Promoters and Preparation Procedures on Reforming of Methane with Carbon Dioxide over Ni/Al2O3 Catalyst