Abstract:Biomass is an important renewable source, which usually requires a depolymerization process before its further utilization for the production of biofuels and chemicals. The continuous hydrothermal catalytic conversion in the packed-bed reactor may provide an effective means for biomass depolymerization; however, the effects of particle characteristics and operating parameters on the fluid flow and mass transfer, as well as the catalytic performance should be further investigated. In this study, a numerical approach was established in a tubular hydrothermal reactor packed with solid acid catalysts. The results show that increasing the catalyst porosity can effectively break the internal diffusion limitation and strengthen the catalytic conversion performance of the substrate by the catalytic bed in the reactor. At a catalyst porosity of 8 %, the maximum average reaction rate increased by 23.6 % when the percentage of macroporous pores increased from 30 % to 90 %, which enhanced the mass transfer inside the catalyst. When the average mesopore pore size increased from 5 nm to 50 nm, the average reaction rate improved by 9.7 % and 7.6 % for the catalyst with low porosity (8 %)and high porosity (50 %), respectively. Increasing the flow rate enhances the average reaction rate inside the catalyst, but also results in a lower glucose yield at the reactor outlet. The reactor outlet had a maximum glucose yield of 4.9 % at a flow rate of 1.3 mL/min. When the substrate concentration increased from 1.0 g/L to 20 g/L, the average reaction rate inside the catalyst increased significantly, but the glucose yield showed a decreasing trend.

STUDY ON DILUTE-ACID HYDROLYSIS OF LIGNOCELLULOSIC BIOMASS(Ⅰ)——DEVELOPMENT OF CONTINUOUS HYDROLYSIS REACTOR

An Apparatus for Continuous Treatment of Solid Wastes by Supercritical and Near-critical Water Reactions

Kinetics of cellulose enzymatic hydrolysis and simultaneous saccharification and lactic acid fermentation process

Study on the two-stage hydrolysis of biomass using acid as catalyst

Simultaneously Saccharification and Lactic Acid Fermentation for Using Cellulosic Material As Raw Material in a Coupling Bioreactor

Study on the Continuous Transportation of Biomass under High Pressure

Continuous Enzymatic Saccharification and Its Rheology Profiling under High Solids Loading of Lignocellulose Biomass

Cellulose Hydrolysis Research for Liquid Fuel Production under Low Concentration Acids

Hydrothermal Conversion Of Glycerin Into Lactic Acid By A Continuous-Flow Reactor

Hydrothermal catalytic conversion of cellobiose by solid acid in a continuous reactor: Effects of the catalyst characteristics and operational parameters

CONTINUOUS CATALYTIC HYDROLYSIS OF CELLULOSE

Experimental Study and Product Analysis of Lignocellulosic Biomass Hydrolysis under Extremely Low Acids

Research on Continuous Hydrothermal Conversion of Glycerin into Lactic Acid

EXPERIMENTAL INVESTIGATION ON HYDROGEN PRODUCTION BY GASIFICATION OF LIGNIN IN SUPERCRITICAL WATER

AN EXPERIMENTAL RESEARCH ON HYDROLYTIC RESIDUES OF LIGNOCELLULOSES WASTE CONVERSION INTO HYDROGEN

CONCENTRATED SULFURIC ACID-HYDROLYSIS OF WOOD CHIPS FOR GLUCOSE

ned pretreatment of dilute acid pre-extraction and chemical-assisted mechanical re fi ning on enzymatic hydrolysis of lignocellulosic biomass

CATALYTIC LIQUEFACTION OF HYDROLYTIC LIGNIN IN SUPERCRITICAL ETHANOL SOLUTION(Ⅰ) EFFECT OF TEMPERATURE,TOTAL ALKALI & SULFIDITY OF CATALYST ON REACTION

Aspect elucidation of a physicochemical pretreatment for continuous decrystallization

Acid Hydrolysis of Lignocellulosic Biomass: Sugars and Furfurals Formation

Dilute Acid Hydrolysis Reaction of Biomass Hemicellulose