Abstract:Mordenite and ZSM-5 seeds could grow on the surface of an asymmetric α-Al2O3 support using an identical organic-free aluminosilicate solution under the same hydrothermal conditions. It suggests that the phase of zeolite can be controlled by varying the type of seed. Continuous mordenite and ZSM-5 membranes were prepared by the secondary growth method using corresponding seeds under appropriate conditions. The water content in the secondary growth mixture strongly influenced the growth of zeolite crystals. ZSM-5 seeds grew at a smaller rate and showed a habit of thin hexagonal plate in a concentrated mixture, while the crystals with a habit of rectangular parallelepiped were formed from a diluted secondary growth mixture. ZSM-5 crystals had poor intergrowth in the former case, whereas the crystals were highly intergrown in the latter case. ZSM-5 crystals in either membrane have a random orientation. In contrast to ZSM-5 zeolite, the crystal orientation in the secondary grown mordenite membranes strongly depended on the water content in the secondary growth mixture. The crystals in the mordenite membrane developed in a diluted secondary growth mixture were oriented with the (150) face parallel to the support surface, whereas the crystals in the membrane grown in a concentrated mixture were oriented with the (002) face parallel to the support surface. These results suggest that the crystal orientation in mordenite membranes can be manipulated only by changing the water content in a secondary growth mixture. The formation of the preferred crystal orientation in the secondary grown mordenite membrane is discussed in terms of an “evolutionary selection” process.

Oriented Films of Epitaxial Mfi Overgrowths

A Facile Fabrication of Highly B-Oriented Mfi Zeolite Films in the Teos-Tpaoh-H2o System Without Additives

Synthesis of highly b-oriented zeolite MFI films by suppressing twin crystal growth during the secondary growth

Oriented Zeolite Mfi Monolayer Films on Metal Substrates by in Situ Crystallization

The control of phase and orientation in zeolite membranes by the secondary growth method

Insights into 1,2-Dihydroxybenzene Addition on Twin Suppression During the Secondary Hydrothermal Synthesis of B-Oriented MFI Zeolite Films

Enhanced Compactness of Oriented MFI Zeolite Films by Heat Treatment of Seed Layer

EPITAXIAL GROWTH OF (0001)ORIENTED 6H-Sic FILMS ON Si(111) SUBSTRATE BY ORGANIC SOL-GEL FILM ANNEALING

Fabrication of B‐oriented MFI Zeolite Films under Neutral Conditions Without the Use of Hydrogen Fluoride

Solvent-Free Secondary Growth of Highly B-Oriented MFI Zeolite Films from Anhydrous Synthetic Powder.

Controlling Crystal Orientation in Zeolite MFI Thin Films by Direct In Situ Crystallization

Growth of Cubic MgxZn1-xO Films and Characterization

Controlled Release of Siliceous Species for the Fabrication of Highly B-Oriented MFI Zeolite Films

Dynamic Hydrothermal Synthesis of a B-Oriented MFI Zeolite Film

Oriented MFI films for gas phase separation, catalysis, and sensing: A review of crystal growth, design, and function enabling

Thermal processing of zeolite seed layers for the fabrication of compact oriented MFI zeolite films

Rapid fabrication of highly b-oriented zeolite MFI thin films using ammonium salts as crystallization-mediating agents

Single-Mode Microwave Heating-Induced Concurrent Out-of-Plane Twin Growth Suppression and In-Plane Epitaxial Growth Promotion of b-Oriented MFI Film under Mild Reaction Conditions

Initial Growth of Bi4 Lati3 Feo15 Thin Films on Srtio3, Mgo and Ysz Substrates

Oriented Growth of Mcm-22 Zeolite Films

Alignment controllable synthesis of MOF films: From Cu(OH)2 nanowire array to highly oriented Cu-MOF film