Abstract:Organic matter and nutrients present in urban and industrial wastewater should be removed or valorised to reduce its impact on the environment. Conventional wastewater treatments are focused on the removal of these pollution sources at the minimum cost. The idea of resource recovery from wastewater is changing the concept of the conventional wastewater treatment plants that tend to incorporate little by little processes as anaerobic digestion, MBR, biofilm, granulation, etc. However, their application to obtain reusable by-products from wastes should be cost effective. Winery wastewater is an effluent with a highly biodegradable organic load, worth considering for biogas production, and low nutrient content. A sidestream anaerobic membrane bioreactor (AnMBR) was started up and operated under organic load oscillations. The stable operation was assured by keeping a ratio between intermediate alkalinity and total alkalinity (IA/TA) below 0.3 achieving a 96.7±2.7% COD removal efficiency. The biogas production varied according with the OLR that was on average 0.50±0.17 m(3)(biogas)/m(-3)(digester)/d(-1) with an 87.1±3.0% of methane. The external membrane module reached a flux of 20.2 ± 8.5 LMH at a crossflow velocity of 0.64 m s-1. The crossflow velocity helped to remove the cake layer attached on the membrane that was the main contribution (>80%) to flux decline. The energy demand of the AnMBR was calculated considering the net energy production of a combined heat and power (CHP) unit. It was concluded that only when influent COD was over 3.25 gCOD 1:1- the energy balance was positive. Considering the upscaling of the AnMBR of the present study, the submerged membrane configuration would be a more feasible option due to its lower operational costs, especially in winter season. Simulating the conditions of winter season, winery wastewater was treated in the AnMBR at low temperatures of 25°C and 15°C. Since the organic load of winery wastewater in winter is much lower than in summer (vintage season), the average OLR applied was 0.32 and 0.29 kgCOD m(-3)(digester)/d(-1) the average COD removal reached was 80% and 71% at 25°C and 15°C., respectively. Moreover, higher degree of fouling was observed despite the amount of suspended solids was lower, so frequent cleanings were necessary. The effluent of anaerobic digestion often requires a post-treatment to remove nutrients, especially nitrogen. Compared with conventional biological nitrogen removal, nitritation/denitritation (N/DN) via nitrite represent a 25% less aeration and 40% less external carbon source. In order to reach higher flexibility and reducing space requirements, N/DN can be carried out in a sequencing batch reactor (SBR). Under feast and famine conditions applied in the SBR, storage compounds can be served as internal carbon sources for post-anoxic denitrification. A novel scheme was developed for the treatment of municipal wastewater; consisting in an UASB reactor followed by a short cut sequencing batch reactor (scSBR) in the main water line. Nitritation/denitritation was integrated with the selection of polyhydroxyalkanoate (PHA) storing biomass. Biowaste fermented liquid was applied as carbon source in the feast regime. The average nitrogen removal was 83%. After achieving an acceptable ammonia removal of 93%, there was enough available PHA for the subsequent denitritation, reaching a maximum nitrite removal of 98%. The maximum PHA content was 10.6% (gPHA gTSS-1) after 10 h of accumulation when biowaste fermented liquid (C/N/P= 100/4.5/0.42) was applied. Nitrogen removal limits could be successfully met while PHA-storing biomass was selected. Although higher PHA yields can be achieved under complete aerobic conditions, this novel scheme presents an added value due to the integration of the PHA production in the nitritation/denitritation process.

Anaerobic Treatment of Winery Wastewater Using Laboratory-Scale Multi- and Single-Fed Filters at Ambient Temperatures

Examining A Hybrid Plug-Flow Pilot Reactor Foranaerobic Digestion of Farm-Based Biodegradable Solids

Hydrogen Production from Rice Winery Wastewater in an Upflow Anaerobic Reactor by Using Mixed Anaerobic Cultures

ANAEROBIC BIOTREATMENT OF WASTEWATER FROM BREWERY FACTORY OF CAMEROON

Research on the Characteristics of Start Up and Operation of Treating Brewery Wastewater with an AFB Reactor at Ambient Temperatures

BIOMETHANATION OF BREWERY WASTEWATER USING AN ANAEROBIC UPFLOW BLANKET FILTER

Domestic wastewater treatment using an anaerobic bioreactor coupled with membrane filtration

Treatment of Winery Wastewater Using Bench-Scale Columns Simulating Vertical Flow Constructed Wetlands with Adsorption Media

Process characteristics and energy self-sufficient operation of a low-fouling anaerobic dynamic membrane bioreactor for up-concentrated municipal wastewater treatment

Effect of Temperature Variation on Codigestion of Animal Waste and Agricultural Residue for Biogas Production

Treatment of distillery vinasse in a high rate anaerobic reactor using low density polyethylene supports

Performance and Microbial Community of a Novel Combined Anaerobic Bioreactor Integrating Anaerobic Baffling and Anaerobic Filtration Process for Low-Strength Rural Wastewater Treatment

Municipal wastewater treatment by an anaerobic hybrid reactor at ambient temperatures

A Half-Submerged Integrated Two-Phase Anaerobic Reactor for Agricultural Solid Waste Codigestion

Biomethane production and microbial strategies corresponding to high organic loading treatment for molasses wastewater in an upflow anaerobic filter reactor

Full-scale study on high-rate low-temperature anaerobic digestion of agro-food wastewater: process performances and microbial community

Hydrogen Production from Rice Winery Wastewater by Using A Continuously-Stirred Reactor

Anaerobic treatment of vinasses by a sequentially mixed moving bed biofilm reactor

A contribution to resource recovery from wastewater. Anaerobic processes for organic matter and nitrogen treatment

Treatment of Ethanol Production Wastewater by Thermophilic ABFR Reactor

Purification of High Strength Wastewater Originating from Bioethanol Production with Simultaneous Biogas Production