Abstract:In an attempt to synthesize novel zirconium phosphate materials, a series of syntheses have been performed in a deep eutectic solvent (DES), composed of tetrapropylammonium bromide (TPABr) and oxalic acid. As a result, this DES does not act as a template provider in reaction probably owing to the steric effects of the longer chains of the TPA cation, and only the alpha-Zr(HPO4)(2). H2O (alpha-ZrP) phase has been achieved. However, after organic amine was added to the initial reaction mixture in a normal way, the additives did act as a template to induce the zirconium phosphate framework. For example, with 1,4-dimethylpiperazine as an additive, a novel layered compound, [C6H16N2](0.5)Zr-(H0.5PO4)2. H2O (denoted as ZrPO4-DES8) was obtained. Its structure was determined from single-crystal X-ray diffraction (XRD) data and consists of zirconium phosphate layers with the protonated 1,4-dimethylpiperazine and water molecules in between. Interestingly, the two layered materials as additives in a liquid lubricant exhibit excellent friction behavior with higher load-carrying and antiwear capacities in comparison to typical lubricant additives such as MoS2 and graphite, increase the P-B value of the base oil by 27.2% and 8.5%, and decrease the wear scar diameter of the base oil by 43% and 36%, respectively. Scanning electron microscopy, XRD, and energy-dispersive X-ray spectrometry are used to investigate the lubricant behavior of those materials.

Organically modification of layered alpha-zirconium phosphate

Surface Modification of Layered Zirconium Phosphate with PNIPAM

Microwave-assisted Rapid Synthesis of Hexagonal Α-Zirconium Phosphate Nanodisks As a Pickering Emulsion Stabilizer

Hydrothermal Synthesis of Layered Α-Zirconium Phosphate Disks: Control of Aspect Ratio and Polydispersity for Nano-Architecture

Studies on the intercalation of n-alkylamine and n-amino-alcohol in layered zirconium phosphate

Preparation And Characterization Of Layered Zirconium Phosphates Based On Water-In-Oil Microemulsion

Studies on Synthesis and Properties of Layered Zirconium Phosphate

Ultrasonic-assisted rapid and highly efficient liquid-phase exfoliation of α-zirconium phosphate

Ionothermal Synthesis Of Layered Zirconium Phosphates And Their Tribological Properties In Mineral Oil

Ionothermal Synthesis and Characterization of Crystalline Zirconium Phosphate from Oxalic Acid/Tetrapropyl Ammonium Bromide System

Studies on the preparation and structure of polyacrylamide/α-zirconium phosphate nanocomposites

Studies on colloidization and stability of layered phosphates in amine hydrous solution

Synthesis, Characterization and Crystal Structure Analysis of an Open-Framework Zirconium Phosphate

Synthesis of Polyacrylamide/α-Zirconium Phosphate Nanocomposite by In-Situ Intercalative Polymerization and the Characterization of Its Structure

Solvothermal Synthesis and Characterization of the Layered Compound of Α-Zirconium Hydrophosphate

Hydrothermal synthesis of layered zirconium phosphates and their intercalation properties

Exfoliation of layered zirconium phosphate nanoplatelets by melt compounding

Preparation of Exfoliated Epoxy/α-Zirconium Phosphate Nanocomposites Containing High Aspect Ratio Nanoplatelets

Exfoliation and Functionalization of Α-Zirconium Phosphate in One Pot for Waterborne Epoxy Coatings with Enhanced Anticorrosion Performance

Synthesis, Structure and Characterization of ZrPOF-DEA, a Microporous Zirconium Phosphate Framework Material

Preparation of Layered Α-Zrp and Alkyldiamine-α-ZrP Intercalation and Characterization