Abstract:The aerodynamic performance of a reduced-scale coaxial rigid rotor system in hover and steady forward flights was experimentally investigated to gain insights into the effect of interference between upper and lower rotors and the influences of the advance ratio, shaft tilt angle and lift offset. The rotor system featured by 2 m-diameter, four-bladed upper and lower hingeless rotors and was installed in a coaxial rotor test rig. Experiments were conducted in the Φ3.2 m wind tunnel at China Aerodynamics Research and Development Center (CARDC). The rotor system was tested in hover states at collective pitches ranging from 0° to 13° and it was also tested in forward flights at advance ratios up to 0.6, with specific focus on the shaft tilt angle and lift offset sweeps. To ensure that the coaxial rotor was operating in a similar manner to that of the real flight, the torque difference was trimmed to zero in hover flight, whilst the constant lift coefficient was maintained in forward flight. An isolated single-rotor configuration test was also conducted with the same pitch angle setting in the coaxial rotor. The hover test results demonstrate that the figure of merit (FM) value of the lower rotor is lower than that of the upper rotor, and both are lower than that of the isolated single rotor. Moreover, the coaxial rotor configuration can contribute to better hover efficiency under the same blade loading coefficient (CT/σ). In forward flight, the effective lift-to-drag (L/De) ratio of the coaxial rigid rotor does not monotonously change as the advance ratio increases. Increases in the required power and drag in the case with a high advance ratio of 0.6 leads to the decreasing L/De ratio of the rotor. Meanwhile, the L/De ratio of the rotor is relatively high when the rotor shaft is tilted backward. The increasing lift offset tends to result in reduced required rotor power and an increase in the rotor drag. When the effect of the reduced rotor power is greater than that of the increased rotor drag, the L/De ratio increases as the lift offset increases. The L/De ratio can benefit significantly from lift offset at a high advance ratio, but it is much less influenced by lift offset at a low advance ratio. The forward performance efficiency of the upper rotor is poorer than that of the lower rotor, which is significantly different from the case in the hover flight.

An Experimental Study on Self-Output-control Characteristics of Micro Downwind Rotor with Coning Soft Blades

An Experimental Study on Self-Output-control Characteristics of Micro Downwind Rotor with Coning Soft Blades

Development of Micro Downwind Turbine Generator Having Soft Blades

An Experimental Study on Aerodynamic Performance of Spiral Savonius Wind Rotor

Design and Hover Test of Low Vibration Mach Scale Rotor with Twisted Composite Tailored Blade

Experimental Study of Two-Stage Savonius Rotors with Different Gap Ratios and Phase Shift Angles

Airfoil Parameterization Evaluation Based on a Modified PARASEC Method for a H-Darrious Rotor

Mechanism Study of Flow Characteristics on small HAWT Blade Surfaces Based on Airfoil Concavity under Yaw Conditions

Investigation on the Performance of a Novel Forward-Folding Rotor Used in a Downwind Horizontal-Axis Turbine

Wind tunnel experiments for innovative pitch regulated blade of horizontal axis wind turbine

The effects of the dual control method on the aerodynamic characteristics of the wind turbine blade

Structure Design and Analysis of a Novel Forward-folding Rotor Used in a Downwind Horizontal-axis Turbine

Dynamic Characteristics and Enhanced Performance of a Novel Wind Turbine Rotor Analyzed Via Experiments and Numerical Simulation

A Novel Folding Blade of Wind Turbine Rotor for Effective Power Control

Experimental and Numerical Investigation of Tubercles and Winglets Horizontal Axis Wind Turbine Blade Design

Wind Tunnel Studies on Hover and Forward Flight Performances of a Coaxial Rigid Rotor

Wind Tunnel Testing and Improved Blade Element Momentum Method for Umbrella-Type Rotor of Horizontal Axis Wind Turbine

Unsteady CFD simulation of a rotor blade under various wind conditions

Experimental investigation of a novel vertical axis wind turbine with pitching and self-starting function

A NEW ACTIVE CONTROL STRATEGY FOR WIND-TURBINE BLADES UNDER OFF-DESIGN CONDITIONS

Research on the rotor speed and aerodynamic characteristics of a dynamic yawing wind turbine with a short-time uniform wind direction variation