Abstract:The application of ceramic dielectrics in various microwave electronic instruments and devices is determined by their properties such as dielectric constant, dielectric loss factor, thermal conductivity, and absorptance. Alumina nitride composites with dielectric losses (high dielectric loss tangent tgδ varying from 0.1 to 0.6 ) are promising functional materials, but there are few publications with detailed dielectric characteristics including thermal conductivity, which is especially important for devices with high output power. To determine the dielectric characteristics (ε′ and tgδ), the resonance measurement method with a cylindrical resonator was employed. The electromagnetic energy absorptance L (attenuation in a bulk absorber with respect to absorber length) was used to compare absorbers of different sizes. Microwave attenuation in the absorber ring located in a resonator of the delay line of the traveling-wave tube model was measured employing a P2-61 panoramic meter for voltage standing wave ratio and attenuation. Experimental values of the real and imaginary ε′′ parts of the complex dielectric constant in pressureless-sintered AlN–SiC composites with different contents and sizes of semiconducting silicon carbide particles are presented. When SiC increases from 20 to 50% in the AlN-based composite, ε′ becomes 1.7–2.1 times higher and ε′′ 5.4–6.8 times higher. The smaller the SiC particles, the greater the increase in ε′ and ε′′, silicon carbide content being the same. The relationship between the thermal conductivity and electromagnetic energy absorptance in the AlN–SiC composites was studied. The range of compromise values was found: they combine relatively high thermal conductivity, 45–55 W/(m · K), and significant absorptance, L = 2.8–3.5 dB/mm, corresponding to the highest silicon carbide content (40–50%) and microsized SiC particles (2.3–4.4 μm). A relationship was established between the imaginarabsorptance L(dB/mm) , allowing the absorptance to be determined from known ε′′ at a frequency of 3.3 GHz.

Nanometer silicon carbide powder synthesis and its dielectric behavior in the GHz range

Dielectric and infrared properties of silicon carbide nanopowders

Studies of synthesizing the SiC nanometer powders by chemical vapor reaction

Synthesis and microwave dielectric properties of (Ca0.7Mg0.3)SiO3 nanopowder prepared at low temperature

Preparation and Dielectric Properties of SiC-AlN Solid Solutions

Influence of the Silicon Carbide Particle Size on Dielectric Characteristics, Thermal Conductivity, and Microwave Absorption of Pressureless-Sintered AlN–(20–50)% SiC Composites

Synthesis and wave absorption characterization of SiC nanowires/expanded graphite composites

Enhanced dielectric and conductivity properties of carbon-coated SiC nanocomposites in the terahertz frequency range

Controllable dielectric properties and strong electromagnetic wave absorption properties of SiC/spherical graphite-AlN microwave-attenuating composite ceramics

On the impact of nitrogen and aluminum doping on silicon carbide polytype stability: Insights from first principle calculations

Wide-Band Microwave Absorption By In Situ Tailoring Morphology And Optimized N-Doping In Nano-Sic

Dielectric and Microwave Absorption Properties of AlN‐SiBCN Lossy Ceramics

Synthesis of N-doped SiC Nano-Powders with Effective Microwave Absorption and Enhanced Photoluminescence

Nitrogen Content Dependent Microwave Absorption Property of Nitrogen-Doped SiC Materials Annealed in N-2: Opposing Trends for Microparticles and Nanowires

Solid solution of Al and N in nano-sized α-SiC powder by carbothermal reduction of the xerogels of SiO2–Al2O3

Synchronous Enhancements in Dielectric Performances and Thermal Conductivity of Β-Sicw/pvdf Nanocomposites Through Building Crystalline SiO2 Shell As an Interlayer

Nanoscale-SiC doping for enhancing Jc and Hc2 in the Superconducting MgB2

Mechanical and Microwave Dielectric Properties of C<sub>sf</sub>/Si<sub>3</sub>N<sub>4</sub> Composites

Electromagnetic wave absorption and mechanical properties of SiC nanowire/low-melting-point glass composites sintered at 580°C in air

Microwave-absorption Properties of Heterostructural SiC Nanowires/sioc Ceramic Derived from Polysiloxane