Abstract:Nowadays, lignocellulosic biomass is considered as renewable source for the substitute of traditional fossil energy resources. The production of biofuel intermediates such as 5-hydroxymethylfurfural (5-HMF), levulinic acid and.-valerolactone (GVL), and commercially interesting compounds such as lactic acid and ethylene glycol from biomass has become an important issue for world-wide researchers. In this work, we focused on the conversion of lignocellulosic biomass into acetic acid through a "one-pot two-step" method over inorganic acids in aqueous media. The first step was the hydrolysis of the raw biomass with sulfuric acid at 190 degrees C, 1.0 MPa N-2 for 1 h. After that, the reaction was changed to 2.0 MPa O-2 and allowed to react for another 9 h. HPLC analysis of the result mixture showed that mass yield of acetic acid from corn stover was up to 21.3%, and the selectivity of acetic acid was as high as 84.6% of the total liquid products. Besides, the other lignocellulosic biomass feedstocks such as corn cob, bagasse, bamboo, poplar and pine were also successfully converted into acetic acid in good yields under the optimized reaction condition. In addition, the stability of the catalyst acid was examined, and the recovery of the catalyst acid is about 95%. Thus, to achieve the reuse of the catalyst acid, the addition of extra 10% catalyst acid after each catalytic cycle was needed. Finally, the reaction pathway was explored by using the components of the lignocellulosic biomass feedstocks as the starting materials (sugars etc.). The results showed that the carbohydrates especially hexoses were the main source of acetic acid. It was dehydrated and hydrolyzed into the intermediate levulinic acid, which was then oxidized into acetic acid by C-C bond oxidative cleavage. The current method provided a new access to the bulk acetic acid from sustainable raw biomass.

A Continuous Flow Reaction System for Producing Acetic Acid by Wet Oxidation of Biomass Waste

A New Hydrothermal Process for Producing Acetic Acid from Biomass Waste

An Apparatus for Continuous Treatment of Solid Wastes by Supercritical and Near-critical Water Reactions

A New Process to Resource Rice Hull

Production of Acetic Acid by Wet Oxidation of Rice Hull and Straw.

Wet Oxidation of Lignin Model Compounds and Acetic Acid Production

Production of Acetic Acid by Hydrothermal Two-Step Process of Vegetable Wastes for Use As A Road Deicer

Hydrothermal Process for Increasing Acetic Acid Yield from Lignocellulosic Wastes

Production of Formic Acid and Acetic Acid by Hydrothermal Oxidation of Alkali Lignin

Hydrothermal conversion of biomass into acetic acid

Production of Acetic Acid from Lignocellulosic Biomass in the Presence of Mineral Acid and Oxygen under Hydrothermal Condition

Wet air oxidation treatment of H-acid wastewater

Production of Acetic Acid from Carbohydrate Biomass by Two-Step Reaction with Alkaline Hydrothermal Reaction and Wet Oxidation

Controlling Hydrothermal Reaction Pathways To Improve Acetic Acid Production From Carbohydrate Biomass

O2-H2O2 High-Efficient Co-Oxidation of Carbohydrate Biomass to Formic Acid Via Co3O4/C Nanocatalyst

Continuous Production of Formic Acid from Biomass in a Three-Phase Liquid–Liquid–Gas Reaction Process

Optimization of Volatile Fatty Acid Production with Co-Substrate of Food Wastes and Dewatered Excess Sludge Using Response Surface Methodology

Effect of Lignin on Acetic Acid Production in Wet Oxidation of Lignocellulosic Wastes

Supercritical Water Oxidation of Acrylic Acid Production Wastewater

Formic Acid Production from Carbohydrates Biomass by Hydrothermal Reaction

Application of hydrothermal reaction to conversion of plant-origin biomasses into acetic and lactic acids