Abstract:Magnesium oxysulfate (MOS) whiskers are commonly synthesized through a dissolution-precipitation mechanism, wherein Mg(OH) 2 dissolves to form Mg(OH) 6 4- , followed by reactions with SO 4 2- and H 2 O to yield MOS whiskers. However, the impact of Mg(OH) 2 precursor properties on the formation process of MOS whiskers has been insufficiently explored, and sector-like and needle-like morphologies were both observed in previous studies. In this study, we systematically investigated how the properties of Mg(OH) 2 precursors influenced the crystalline structure and morphology of MOS whiskers. Under various experimental conditions, MgSO 4 ·5Mg(OH) 2 ·2H 2 O (152MOS) whiskers were consistently obtained, regardless of Mg(OH) 2 morphology and size. The size of Mg(OH) 2 emerged as a critical factor in shaping the morphology of 152MOS whiskers. Smaller-sized Mg(OH) 2 (≤106±37 nm) favored the formation of sector-like whiskers, while larger-sized Mg(OH) 2 (≥206±98 nm) encouraged the development of needle-like whiskers. This distinction was attributed to the slower dissolution rate exhibited by larger-sized Mg(OH) 2 , maintaining a smaller number of 152MOS nuclei and promoting the growth of needle-like whiskers instead of the aggregation of 152MOS nuclei into sector-like structures. In addition, the effects of the molar ratio of Mg 2+ to SO 4 2- and hydrothermal temperature were also studied. The average length and diameter of the needle-like whiskers prepared with Mg(OH) 2 of 331±145 nm under optimized conditions were 77±32 and 0.39±0.10 μm, respectively. This study presented an effective strategy for controlling the morphology of 152MOS whiskers.

Study on preparation of basic magnesium sulfate whiskers from boron slurry

Study on Preparation of MgO Crystal Whisker from Magnesite

Preparation and Characterization of Novel 5Mg(OH)2·MgSO4·7H2O Whiskers

Preparation and Characterization of Magnesium Hydroxide Sulfate Hydrate Whiskers

Hydrothermal formation and characterization of magnesium oxysulfate whiskers

Hydrothermal Synthesis Process of Magnesium Oxysulfate Whiskers

Preparation of barium sulfate submicro-particles with high purity by solventing-out process

Synthesis Of Magnesium Oxysulfate Whiskers In The Presence Of Sodium Dodecyl Benzene Sulfonate

Low-Cost Synthesis and Morphology Control of Magnesium Oxysulfate Hydrate Whiskers

Study on preparing technology of MgO whisker with MgSO_4 as raw material

Synthesis and characterization of MgSO4·5Mg(OH)2·2H2O flake powders

Hydrothermal formation of magnesium oxysulfate whiskers in the presence of ethylenediaminetetraacetic acid

Effects of the properties of Mg(OH) 2 precursor on the hydrothermal synthesis of magnesium oxysulfate whiskers

Hydrothermal Formation of Magnesium Hydroxide Sulfate Whiskers

Preparation of boric acid and magnesium hydroxide from boron-rich slag by hydrochloric acid leaching method

Controllable Synthesis of Mg(OH) 2 Whiskers Using 5Mg(OH) 2 ·MgSO 4 ·2H 2 O Whiskers with Tunable Diameter as Precursors

Study on the Recovery of Magnesium Sulfate Heptahydrate from Brine Sludge Produced in Soda Industry

Preparation of magnesium hydroxide by ammonia gas method

Hydrothermal Synthesis and Characterization of Magnesium Borate Hydroxide Nanowhiskers

Effect of MgO and NH 4 OH on Formation of 5Mg(OH) 2 ·MgSO 4 ·3H 2 O Whiskers

Research on MgSO 4 Whiskers Grown on the Surface of Porous Materials