Abstract:Magnesium oxysulfate (MOS) whiskers are commonly synthesized through a dissolution-precipitation mechanism, wherein Mg(OH) 2 dissolves to form Mg(OH) 6 4- , followed by reactions with SO 4 2- and H 2 O to yield MOS whiskers. However, the impact of Mg(OH) 2 precursor properties on the formation process of MOS whiskers has been insufficiently explored, and sector-like and needle-like morphologies were both observed in previous studies. In this study, we systematically investigated how the properties of Mg(OH) 2 precursors influenced the crystalline structure and morphology of MOS whiskers. Under various experimental conditions, MgSO 4 ·5Mg(OH) 2 ·2H 2 O (152MOS) whiskers were consistently obtained, regardless of Mg(OH) 2 morphology and size. The size of Mg(OH) 2 emerged as a critical factor in shaping the morphology of 152MOS whiskers. Smaller-sized Mg(OH) 2 (≤106±37 nm) favored the formation of sector-like whiskers, while larger-sized Mg(OH) 2 (≥206±98 nm) encouraged the development of needle-like whiskers. This distinction was attributed to the slower dissolution rate exhibited by larger-sized Mg(OH) 2 , maintaining a smaller number of 152MOS nuclei and promoting the growth of needle-like whiskers instead of the aggregation of 152MOS nuclei into sector-like structures. In addition, the effects of the molar ratio of Mg 2+ to SO 4 2- and hydrothermal temperature were also studied. The average length and diameter of the needle-like whiskers prepared with Mg(OH) 2 of 331±145 nm under optimized conditions were 77±32 and 0.39±0.10 μm, respectively. This study presented an effective strategy for controlling the morphology of 152MOS whiskers.

Study on Preparation of MgO Crystal Whisker from Magnesite

Study on preparing technology of MgO whisker with MgSO_4 as raw material

Preparation and Characterization of Novel 5Mg(OH)2·MgSO4·7H2O Whiskers

Fabrication of Y2O3-doped MgO Refractory Raw Materials Based on Magnesium Hydroxide from Salt-Lake Brine

Hydrothermal formation and characterization of magnesium oxysulfate whiskers

Preparation and Characterization of Magnesium Hydroxide Sulfate Hydrate Whiskers

Research Progress of Preparation of Magnesium Carbonate Whisker

Activated treatment of magnesite for preparing size-controlled Mg2B2O5 whiskers and their microwave dielectric properties

Controllable Synthesis of Mg(OH) 2 Whiskers Using 5Mg(OH) 2 ·MgSO 4 ·2H 2 O Whiskers with Tunable Diameter as Precursors

Hydrothermal formation of magnesium oxysulfate whiskers in the presence of ethylenediaminetetraacetic acid

Effect of MgO and NH 4 OH on Formation of 5Mg(OH) 2 ·MgSO 4 ·3H 2 O Whiskers

Synthesis and characterization of MgSO4·5Mg(OH)2·2H2O flake powders

Effects of the properties of Mg(OH) 2 precursor on the hydrothermal synthesis of magnesium oxysulfate whiskers

Formation mechanism of whiskers in Al–MgAl2O4–MgO refractories at 1400 °C under N2 atmosphere

Effect of Magnesium Oxide on Preparation of Mullite Fibers Via Sol-Gel Method

Low-Cost Synthesis and Morphology Control of Magnesium Oxysulfate Hydrate Whiskers

Preparation and thermal decomposition of 5Mg(OH)2·MgSO4·2H2O nanowhiskers

Synthesis Of Magnesium Oxysulfate Whiskers In The Presence Of Sodium Dodecyl Benzene Sulfonate

A Technology of Preparing Honeycomb-Like Structure Mgo from Low Grade Magnesite

Formation and Phase Transformation of MgCO 3 ·3H 2 O Whiskers in the Presence of Sodium Dodecyl Sulfate

Hydrothermal Synthesis Process of Magnesium Oxysulfate Whiskers