Abstract:Natural gas, known for its high combustion efficiency and low CO 2 emissions, is experiencing a significant increase in both market share and application range. Despite these advantages, there are also challenges emerged during the combustion process, including occurrence of high flame temperature, difficulty in controlling nitrogen oxide emissions, combustion instability, and a tendency to backfire. To address these issues and achieve clean and stable burning, a novel 14MW water-cooled pre-mixed burner has been developed. In-depth simulations are conducted to assess the impact of various structural and operating parameters on combustion and pollutant emission characteristics. Results indicate that the combustion temperature follows a "W" shape with height of the low cooling component while its width governs combustion stability. Gas inlet spacing influences the flame center position and anti-backfire performance. The flare angle of gas channels determines the minimum ignition energy of the mixed gas fuel which affects ignition point and flame center position. Although large height of high cooling component contributes to low NO x emissions at the gas outlet, the resultant low temperature is undesirable for combustion stability. Further examinations of operating parameters through simulations reveal that combustion temperature initially decreases and then increases with excess air coefficient, while a significant decrease is noted with lower operating load. The premixed water-cooled technology could achieve low-NO x emissions to 2.89 mg·Nm -3 with the combustion temperature controlled at 1642K. This study provides valuable data for the design of low-NO x gas burners, serving as a reference for achieving clean and stable combustion of gas fuel.

STUDIES ON NO_x EMISSION IN A NATURAL GAS PILOT BOILER WITH INTERNAL FLUE GAS RECIRCULATION

Research on Full Premixed Combustion and Emission Characteristics of Non-Electric Gas Boiler

Numerical Simulation Study on Combustion Characteristics and NOx Emission of COREX Gas Swirl Burner and Boiler

Experiment and Numerical Simulation Study of Low-nitrogen Combustion Technology inside Small Gas Boiler

Numerical Studies of a Water-cooled Premixed Burner for Low NO x Combustion of Natural Gas

Numerical Simulation of NOx Formation in Non-Premixed Methane Combustion Using Internal Flue Gas Recirculation

Investigation of NOx emission under different burner structures with the optimized combustion model

Study on Nitrous Oxide Emission in Boiler Furnace

Experimental Investigation on the Conversion of Fuel-N to NOx of Quasi-Particle in Flue Gas Recirculation Sintering Process

EXPERIMENTAL STUDY ON THE PROPERTY OF Nox EMISSION IN HIGH TEMPERATURE COMBUSTION OF COMMONLY USED COAL SORTS AND THEIR MIXTURES IN LARGE-SCALE TANGENTIALLY FIRING PULVERIZED COAL BOILERS

Numerical Simulation of NO x Emission Characteristics of a Cyclone Boiler with Slag-Tap Furnace

Numerical Study of the Combustion Process in the Vertical Heating Flue of Air Staging Coke Oven

Low NOx Combustion Mechanism of a Natural Gas Burner With Fuel-staged and Flue Gas Recirculation

NO2 formation in natural gas-fired boilers

Study on Prompt NOx Emission in Boilers

STUDY ON NUMERICAL SIMULATION OF DECREASING NOx EMISSION FROM COAL-FIRED BOILERS BASED ON BFA AND OFA

Numerical study of mixing characteristic between flue and droplet at 410t/h coal-fired boiler SNCR system

Experimental study on combustion and NOx emission characteristics of Zhehun blended coal

The numerical simulation and experimental research of Low-NOx burner retrofittingon a 420 T/h utility boiler

Experimental Study and Simulation of NOx Formation by Oxygen-enriched Combustion in a Mini-CFB

Effects of Flue Gas Recirculation on Emissions from a Small Scale Wood Chip Fired Boiler