Abstract:During austenite to ferrite transformation, the lattice structure transforms from fcc to bcc, resulting in a clearly distinguishable austenite and ferrite interface. The short range diffusion of the Fe and C atoms across the interface causes its movement, referred to as interface migration. On the other hand, the C rejected by the ferrite during the austenite to ferrite transformation in Fe- C alloys accumulates ahead of the moving interface. This pile-up of C atom is dependent on the long range diffusion of C in austenite and also influences the ferrite growth kinetics. Experimental observations indicate that dislocations are always migrating with ledges during ledgewise growth. The local stress field of dislocations is considered to alter the solute concentration at the riser of ledges and causes a complex diffusion field interaction among ledges as they migrate. Some established works by other researchers have already taken the effect into consideration when studying phase transformation kinetics. However, these works were limited in diffusion control cases and could hardly explain some experimental results. In this work, a ledgewise growth model considering migration of austenite/ferrite interface, C diffusion in austenite and especially elastic interactions between dislocations moving with ferrite ledges was established, and all the simulated results were qualitatively similar to the reported experimental results. Calculated results showed that the C concentration at the riser of ledges was changed by the elastic stress of these dislocations, which would further change the growth behavior of ledges. In the growth behavior simulations of two ledges, the horizontal distance of the two ledges was found to be a key role to determine the growth kinetics. When the horizontal distance of two ledges was larger than the critical distance, an attractive phenomenon of the two ledges was found to decelerate the leading step; while a repulsive phenomenon of the two ledges which would accelerate the leading ledge if the horizontal distance was smaller than this value. Compared with the simulation results without considering elastic interactions between dislocations, however, in the growth behavior simulations of multi-ledge with elastic dislocation interactions, the coalescence behavior of ledges and growth rate of the leading step were both changed.

Experiments Proving the Mixed Control of the Reactive Diffusion System Zn/Fe3Si with Clamp Press

Assessment of Mobilities of the B2 Phase in the Nickel-Chromium-Aluminum System

Rapid Solidification of Non-Stoichiometric Intermetallic Compounds: Modeling and Experimental Verification

Mesoscale Investigation of Reaction–diffusion and Structure Evolution During Fe–Al Inhibition Layer Formation in Hot-Dip Galvanizing

A novel analytical approach to describe the simultaneous diffusional growth of multilayer stoichiometric compounds in binary reactive diffusion couples

Transformation character of ferrite formation by a ledge mechanism under a mixed-control model

A finite element simulation on fully coupled diffusion, stress and chemical reaction

A model for the compositions of non-stoichiometric intermediate phases formed by diffusion reactions, and its application to Nb3Sn superconductors

A new scheme for simulating diffusion-controlled growth in multi-component alloys

Diffusion Modelling on the Microstructure Evolution in MCrAlY-Superalloy System

Lengthening Kinetics of Pro-Eutectoid Ferrite Ledge in Fe-C Alloy under Interface-Diffusion Mixed Control Mode

Interdiffusion and atomic mobility of the Mg-Ag-Zn system

Study on Diffusion Kinetics and Law of Chromium on the Surface of Low-Carbon Steel

Stresses from Solid State Reactions: a Simple Model, Silicides

Investigating the Influence of Diffusion on the Cohesive Zone Model of the SiC/Al Composite Interface

Diffusion kinetics for fcc quinary Cu–Co–Mn–Ni–Si system and its application to precipitation simulations

Non-Equilibrium Diffusion-Controlled Melting and Re-Solidification of Thin Metal Layers on a Reactive Substrate

Investigation on the temperature-dependent diffusion growth of intermetallic compounds in the Mg-Al-Zn system: Experiment and modeling

Diffusion-Controlled Melting and Re-Solidification of Metal Micro Layers on A Reactive Substrate

SIMULATION OF GROWTH KINETICS OF PRO-EUTECTOID FERRITE USING MIXED CONTROL MODEL WITH CONSIDERATION OF DISLOCATION INTERACTION

Kinetics of diffusion-controlled transformations: Application of probability calculation