Abstract:Glass formation has been studied in Nd60Fe30Al10 alloy produced by melt-spinning, water quenching and copper mold chill casting. Partially amorphous alloys were obtained by melt-spinning at low wheel speeds of 5 to 15 m/s and by water quenching of a 1-mm diameter rod, while fully amorphous alloys were obtained by melt-spinning at higher wheel speeds of 20 and 30 m/s and chill casting of a 1-mm diameter rod. A high coercivity was observed in the partially amorphous ribbon melt-spun at 5 m/s and water quenched rod, and in the fully amorphous chill cast rod, while low values of coercivity were obtained in fully amorphous ribbons melt-spun at high speeds of 20 and 30 m/s. Crystallization of water quenched and chill cast samples after heat treatment at high temperature resulted in a substantial reduction of the high coercivity. Results of X-ray diffraction indicate that formation of Nd and a ternary Fe–Nd–Al phase with an unknown crystal structure were present after crystallization. TEM results and a magnetic study of the heat treated samples indicate that as long as there is an amorphous phase produced by low cooling rate, the high coercivity remains. The high coercivity of bulk amorphous samples is discussed. The unknown ternary Fe–Nd–Al phase is antiferromagnetic with a Neel temperature at about 260 K.

Characterization of a new Nd-Fe-O compound in Nd34Fe60O6 alloy

A Stable NdFeO Ternary Compound in Nd34Fe60O6 Alloy

Dependence of the crystal structure of the Nd-rich phase on oxygen content in an Nd–Fe–B sintered magnet

A Nd-Fe-O Intergranular Phase In Nd-Fe-B Sintered Magnets And Its Effect On Coercivity

The microstructure and ferroelectric property of Nd-doped multiferroic ceramics Bi0.85Nd0.15FeO3

Characterization of the disproportionated NdFeCoZrB alloy by means of electron microscopy

Metastable Nd2(Fe1−xCox)23B3 (0≤x≤1.0) Compounds with the 2:23:3-Type Structure

TEM and XAS Characterization of Hard Magnetic Phase in Nd-Fe Alloys

A New Stable Ferromagnetic Phase In Nd-Fe-B Magnets And Its Effect On Coercivity

Effects of Nd and Co on thermal stability of nanocomposite Nd2Fe14B/a-Fe magnets

Structure and Magnetic Characterization of Amorphous and Crystalline Nd–Fe–Al Alloys

Magnetic phase transitions and magnetic properties of nd3(fe, mo)29 compound and its nitride

Study on the crystal structure refinement and magnetic properties of Al doped NdFeO3 system

Magnetic Characteristics of the Ferromagnetic Fe-rich Clusters in Bulk Amorphous Nd60Fe30Al10 Alloy

Phase component and Curie temperature of Nd4(Fe1-xCrx)77.5B18.5 alloys

Phase Transformation and Magnetic Properties of Mechanically Alloyed Ndfe12-Xmoxny

Structure and magnetic properties of low-neodymium Nd-Fe-B powders by mechanical alloying

Microstructure Evolution in a Cast and Homogenized Nd-Fe-B-Cu Alloy: Experimental Study and Thermodynamic Calculations

Magnetic Properties of Amorphous Nd2(Fe1−xCox)23

Nonequilibrium phase transformation of NdFe11Ti compound during mechanical milling

Structure and magnetic phase diagram of mixed rare-earth Nd1−xTbxFe10.5Mo1.5 compounds