Abstract:Structural transitions of polyamide 46 (PA46) films during the tensile stretch at temperatures from 37 to 249 °C were studied using in situ synchrotron radiation wide-angle X-ray diffraction (SR-WAXD) and Fourier transform infrared (FTIR) techniques. The structural evolution during the stretch at different temperatures can be roughly divided into three regions. In region I (37 ≤ T < 180 °C), stretch enlarges the d-spacing gap between the (100) and (010/110) planes of α phase (triclinic), which is opposite to that during heating. In region II (180 ≤ T < 230 °C), stretch induces a reverse Brill transition, which is characterized by the single diffraction of γ phase (pseudohexagonal) splitting into two diffractions of α phase, while further increasing the strain drives the two split diffractions to transform to a single broad diffraction. As in situ FTIR measurements reveal the continuously increasing content of trans conformation, we speculate that stretch may induce a new form, which is an intermediate structure close to both α and γ phases (named α′ phase) at large strain. In region III (230 ≤ T ≤ 249 °C), the γ phase may skip the α phase and directly transform into the α′ phase. The nonequilibrium crystal phase diagrams of PA46 were constructed in the strain–temperature space and true stress–temperature space. Current results demonstrate that stretch plays a countereffect of heating on the Brill transition of PA46.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.macromol.0c00542?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.macromol.0c00542</a>.Crystal structure confirmation of PA46; the possible unit cell orientation and WAXD pattern of spherulitic aggregates; 1D WAXD integration profiles and the corresponding quantitative results; and in situ FTIR curves and stress–strain curves for FTIR experiments (<a class="ext-link" href="/doi/suppl/10.1021/acs.macromol.0c00542/suppl_file/ma0c00542_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Micro‐FT‐IR Study of Stretching a Single Filament: Polymorphic Transition in Nylon 6

Structural Evolutions of Initially Amorphous Polymers During Near-Tg Stretching: A Minireview of Recent Progresses

Effects of stretching on crystalline phase structure and morphology of hard elastic PVDF fibers

Structure Evolution and Properties Enhancement of Polyamide‐6/polyamide‐1010 Films under Uniaxial and Biaxial Stretching

Aging-dependent Strain Localization in Amorphous Glassy Polymers: from Necking to Shear Banding

The effect of stretching on polyamide – 6: assessment of crystallinity, mechanical properties, and surface roughness

Stretch-Induced Reverse Brill Transition in Polyamide 46

Deformation Mechanisms of Polymer Thin Films by Simultaneous Kinetic Measurement of Microscopic Infrared Dichroism and Macroscopic Stress. Part Iii: Influence of Morphology on Molecular Orientation of Isotactic Polypropylene Films Subjected to Uniaxial Stretching

Inhomogeneous Deformation of Microcrystalline Region in Isotactic Polypropylene Film Revealed by A Simultaneous Kinetic Measurement of Microscopic Infrared Dichroism and Macroscopic Stress

Stretch-induced structural transition of linear low-density polyethylene during uniaxial stretching under different strain rates

INFLUENCE OF THERMAL TREATMENT ON CRYSTAL MELTING BEHAVIOR AND CRYSTAL STRUCTURE OF NYLON 6 AND POLYAMIDE BLOCK COPOLYMER/NYLON 6 BLENDS

Application of an Interpenetrating Network Model to the Necking in the Microcrystalline Region in Four Annealed Isotactic Polypropylene Films Subjected to Uniaxial Stretching at Room Temperature

Plastic deformation of the microfibrils in wet polyacrylonitrile fibers induced by the stretching field

Annealing-induced oriented crystallization and its influence on the mechanical responses in the melt-spun monofilament of poly(L-lactide)

Phase stability and melting behavior of the α and γ phases of nylon 6

Investigation On The Crystalline Transition Of Nylon-6 18

Effect of Thermal Oxidative Aging on the Crystallization Behavior and Properties of Nylon-6

Revisiting the Thermal Transition of Β-Form Polyamide-6: Evolution of Structure and Morphology in Uniaxially Stretched Films

Stretch-Induced Α-to-β Crystal Transition and Lamellae Structural Evolution of Poly(butylene Adipate-Ran-terephthalate) Aliphatic–Aromatic Copolyester

Deformation Mechanisms of Polymer Thin Films by Simultaneous Kinetic Measurement of Microscopic Infrared Dichroism and Macroscopic Stress. 2. Molecular Orientation During Necking Process of Isotactic Polypropylene

Brill transition of nylon-6 in electrospun nanofibers