Abstract:Hypothesis: Bacillariophyceae (i.e., diatoms) are an important class of algae with potential use in the production of proteins and lipids including long-chain ω-3 polyunsaturated fatty acids. Biphasic extraction of microalgae lipids using water-immiscible solvents such as hexane, can avoid the excessive energy required to distil solvents from water, but generally requires energy-intensive rupture of the cells. The unique cell structure and surface chemistry of diatoms compared to other microalgae species might allow biphasic lipid extraction without prior cell rupture. Experiments: The kinetics of biphasic lipid extraction from intact Navicula sp. cells was investigated during low-shear and high-shear mixing, and with prior or simultaneous application of ultrasound (20 kHz at 0.57 W/mL). Dynamic interfacial tension measurements and electron microscopic analysis were used to investigate lipid extraction in relation to interfacial behaviour and cell structure. Results: High yields (>80%) of intracellular lipids were extracted from intact cells over the course of hours upon low-shear contacting with hexane. The cells associated with and stabilised the hexane-water interface, allowing hexane to infiltrate pores in the frustule component of the cell walls and access the intracellular lipids. It was shown that mucilaginous extracellular polymeric substances (EPS) bound to the cell walls acted as a barrier to solvent penetration into the cells. This EPS could be removed by prior ultrasonication. Biphasic extraction was greatly accelerated by shear applied by rotor-stator mixing or ultrasound. High-shear could remove mucilaginous EPS from the cell surfaces to facilitate direct contact of the cell surface with hexane and produced smaller emulsion droplets with increased surface area. The combination of high-shear in the presence of hexane resulted in the in-situ rupture of the cells, which greatly accelerated lipid extraction and allowed high yields of neutral lipid (>95%) to be recovered from freshly harvested cells within less than 5 min. The study demonstrated the ability of shear to enable simultaneous cell rupture and lipid extraction from a diatom alga based on its cell structure and interfacial behaviour.

Mechanism of Lipid Extraction from Botryococcus Braunii FACHB 357 in a Biphasic Bioreactor

Liquid Biphasic Systems for Oil-Rich Algae Bioproducts Processing

Optimization of Cell Disruption and Transesterification of Lipids from Botryococcus braunii LB572

Screening, Purification, and Characterization of an Extracellular Lipase from Aureobasidium Pullulans Isolated from Stuffed Buns Steamers.

Improved Fluorescence Spectrometric Determination of Lipid Content in Botryococcus Braunii

Subcritical water extraction of lipids from wet algae for biodiesel production

In Situ Ethyl Ester Production from Wet Algal Biomass under Microwave-Mediated Supercritical Ethanol Conditions

Application of Memberane Dispersion for Enhanced Lipid Milking from Botryococcus Braunii FACHB 357.

CO2 capture/biofixation and lipid extraction by membrane contactors for enhancing microalgal cultivation

Interplay between interfacial behaviour, cell structure and shear enables biphasic lipid extraction from whole diatom cells (Navicula sp.)

Enzymes Produced by Biomass-Degrading Bacteria Can Efficiently Hydrolyze Algal Cell Walls and Facilitate Lipid Extraction

Lipids extraction from the green alga Ankistrodesmus falcatus using different methods

Screening of Biocompatible Organic Solvents for Enhancement of Lipid Milking from Nannochloropsis Sp.

Solvent-free Lipid Extraction from Microalgal Biomass with Subcritical Water in a Continuous Flow Reactor for Acid-Catalyzed Biodiesel Production

A Novel Process on Lipid Extraction from Microalgae for Biodiesel Production

Enzymatic Ethanolysis Subjected to Schizochytrium Biomass: Sequential Processing for DHA Enrichment and Biodiesel Production

Optimization of a novel lipid extraction process from microalgae

Improved Aqueous Extraction of Microalgal Lipid by Combined Enzymatic and Thermal Lysis from Wet Biomass of Nannochloropsis Oceanica.

Investigation on Cell Disruption Techniques and Supercritical Carbon Dioxide Extraction of Mortierella alpina Lipid

Rapid extraction of lipid from wet microalgae biomass by a novel buoyant beads and ultrasound assisted solvent extraction method

Current Pretreatment/Cell Disruption and Extraction Methods Used to Improve Intracellular Lipid Recovery from Oleaginous Yeasts