Abstract:Marine microalga Nannochloropsis is a promising source for the production of renewable and sustainable biodiesel in replacement of depleting petroleum. Other than biodiesel, Nannochloropsis is a green and potential resource for the commercial production of nutraceutical eicosapentaenoic acid (EPA, C20:5). In recent studies, low-value biodiesel can be achieved by transesterification of Nannochloropsis biomass. However, it is undoubtedly wasteful to produce microalgal biodiesel containing EPA from nutritional and economical aspects. A new strategy was addressed and exploited to produce low-value bulky biodiesel along with EPA enrichment via enzymatic ethanolysis of Nannochloropsis biomass with a specific lipase. Cellulase pretreatment on Nannochloropsis sp. biomass significantly improved the biodiesel conversion by direct ethanolysis with five enzymes from Candida antarctica (CALA and CALB), Thermomyces lanuginosus (TL), Rhizomucor miehei (RM), and Aspergillus oryzae (PLA). Among these five biocatalysts, CALA was the best suitable enzyme to yield high biodiesel conversion and effectively enrich EPA. After optimization, the maximum biodiesel conversion (46.53–48.57%) was attained by CALA at 8:1 ethanol/biomass ratio (v/w) in 10–15% water content with 10% lipase weight at 35 °C for 72 h. Meanwhile, EPA (60.81%) was highly enriched in microalgae NPLs (neutral lipids and polar lipids), increasing original EPA levels by 1.51-fold. Moreover, this process was re-evaluated with two Nannochloropsis species (IMET1 and Salina 537). Under the optimized conditions, the biodiesel conversions of IMET1 and Salina 537 by CALA were 63.41% and 54.33%, respectively. EPA contents of microalgal NPLs were 50.06% for IMET1 and 53.73% for Salina 537. CALA was the potential biocatalyst to discriminate against EPA in the ethanolysis of Nannochloropsis biomass. The biodiesel conversion and EPA enrich efficiency of CALA were greatly dependent on lipidic class and fatty acid compositions of Nannochloropsis biomass. CALA-catalyzed ethanolysis with Nannochloropsis biomass was a promising approach for co-production of low-value biodiesel and high-value microalgae products rich in EPA.

Enzymes Produced by Biomass-Degrading Bacteria Can Efficiently Hydrolyze Algal Cell Walls and Facilitate Lipid Extraction

Subcritical water extraction of lipids from wet algae for biodiesel production

Enzymatic Ethanolysis Subjected to Schizochytrium Biomass: Sequential Processing for DHA Enrichment and Biodiesel Production

Optimization of Cell Disruption and Transesterification of Lipids from Botryococcus braunii LB572

Combined Enzymatic and Mechanical Cell Disruption and Lipid Extraction of Green Alga Neochloris oleoabundans

Multiple Applications of Enzymes Induced by Algal Biomasses from a New Bacillus Isolate to Saccharify Algae and Degrade Chemical Dyes

Improved Aqueous Extraction of Microalgal Lipid by Combined Enzymatic and Thermal Lysis from Wet Biomass of Nannochloropsis Oceanica.

Synergistic Effect of Ultrasound and Switchable Hydrophilicity Solvent Promotes Microalgal Cell Disruption and Lipid Extraction for Biodiesel Production.

Microbial Population Changes in Decaying Ascophyllum nodosum Result in Macroalgal-Polysaccharide-Degrading Bacteria with Potential Applicability in Enzyme-Assisted Extraction Technologies

Cost-effective biodiesel production from wet microalgal biomass by a novel two-step enzymatic process.

Enzymatic utilization of oil and lignocellulosic biomass using halophilic marine bacteria Micrococcus luteus and Pseudoalteromonas peptidolytica

Secretion of Acetylxylan Esterase From Chlamydomonas reinhardtii Enables Utilization of Lignocellulosic Biomass as a Carbon Source

In Situ Enzymatic Conversion of Nannochloropsis oceanica IMET1 Biomass into Fatty Acid Methyl Esters

Highly-Efficient Enzymatic Conversion of Crude Algal Oils into Biodiesel

Microalgae biomass pre-treatment with deep eutectic solvent to optimize lipid isolation in biodiesel production

Optimization of Enzymatic Cell Disruption for Improving Lipid Extraction from Schizochytrium sp. through Response Surface Methodology.

Utilization of enzymatic cell disruption hydrolysate of Chlorella pyrenoidosa as potential carbon source in algae mixotrophic cultivation

A Novel Process on Lipid Extraction from Microalgae for Biodiesel Production

Cell Wall Breaking of Haematococcus pluvialis Biomass Facilitated by Baijiu jiuqu Fermentation with Simultaneously Production of Beverages

Direct Enzymatic Ethanolysis of Potential Nannochloropsis Biomass for Co-Production of Sustainable Biodiesel and Nutraceutical Eicosapentaenoic Acid

Mechanism of Lipid Extraction from Botryococcus Braunii FACHB 357 in a Biphasic Bioreactor