Abstract:Based on the recently constructed n-body potential, both molecular dynamics and Monte Carlo simulations revealed that the Al-Zr amorphous alloy or metallic glass can be obtained within the composition range of 24–66 at. % Zr. The revealed composition range could be considered the intrinsic glass-forming range and it quantitatively indicates the glass-forming ability of the Al-Zr system. The underlying physics of the finding is that, within the composition range, the amorphous alloys are energetically favored to form. In addition, it is proposed that the energy difference between a solid solution and the amorphous phase could serve as the driving force of the crystalline to amorphous transition and the driving force should be sufficiently large for amorphization to take place. The minimum driving forces for fcc Al-based and hcp Zr-based Al-Zr solid solutions to amorphize are calculated to be about −0.05 and −0.03 eV/atom, respectively, whereas the maximum driving force is found to be −0.23 eV/atom at the alloy stoichiometry of Al60Zr40. A thermodynamics parameter γ¯, defined as the ratio of the driving force to the formation energy of the solid solution, is further proposed to indicate the glass-forming ability of an Al-Zr alloy. Thermodynamics calculations show that the glass-forming ability of the Al56Zr44 alloy is the largest, implying that the Al56Zr44 amorphous alloy is more ready to form than other alloys in the Al-Zr system. Besides, Voronoi analysis found that there exists a strong correlation between the coordinate number and structure. Amorphization could result in increase of coordinate numbers and about 1.5% volume-expansion. The volume-expansion induced by amorphization can be attributed to two factors, i.e., the total bond number of the Al-Zr amorphous phase is greater than that of the corresponding solid solution, and the averaged bond length of the Al-Zr amorphous phase is longer than that of the corresponding solid solution. For the Al-Zr alloys, especially for the Al-Zr amorphous phase, there exists a negative chemical micro-inhomogeneity in the alloys, suggesting that metallic bonds prefer to be formed between the atoms of dissimilar species. Finally, it is found that there is a weak correspondence between the bond-angle distributions of Al-Zr amorphous alloys and the solid solutions. It is further suggested that the configuration of Al-Zr amorphous alloys embodies some hybrid imprint of bcc, fcc, and hcp structures. More interestingly, the short-range order is also observed in the bond-angle distributions.

“Soft” Atoms in Zr70Pd30 Metal–metal Amorphous Alloy

On the atomic structure of Zr–Ni and Zr–Ni–Al metallic glasses

The effect of annealing on the electronic stability of an amorphous Zr70Pd30 alloy

Atomic Structure in Zr70cu29pd1 Metallic Glass

Nano-sized Amorphous Cu–Zr Alloy Particles Prepared by Mechanochemical Reaction

The Microstructure and Mechanical Properties of As-cast Mg-10Gd-3Y-xZn-0.6Zr (x=0, 0.5, 1 and 2 Wt%) Alloys

Atomic and electronic structure of amorphous Al–Zr alloy films

Synchrotron x-ray total scattering and modeling study of high-pressure-induced inhomogeneous atom reconfiguration in an equiatomic Zr 50 Cu 50 metallic glassy alloy

Structural and elastic properties of Pd-Zr compounds studied by ab initio calculation

Formation and Structure of Pd-Zr Metallic Glasses Studied by Molecular Dynamics Simulations

Ab Initio Molecular Dynamics Simulation on the Glass Forming Ability of Ni-Metalloid Amorphous Alloys

An ab initio simulation and experimental studies of the glass-forming ability and properties of Al86Ni(14-x)Zrx (x = 1∼7) alloys

Structure of the amorphous, massive-metallic-glass forming Ni 25 Zr 60 Al 15 alloy from molecular dynamics simulations

First Principle Md Study On The Structural And Electronic Properties Of Liquid And Amorphous Ni81b19 And Ni80p20 Alloy

Atomic Packing and Short-to-medium Range Order Evolution of Zr-Pd Metallic Glass

Structural and magnetic properties of the nanocrystalline alloy Fe86Zr7Cu1B6

A combined experimental and ab initio molecular dynamics study on a novel B-based B50Sm10Co40 amorphous alloy

Formation and structure of Al-Zr metallic glasses studied by Monte Carlo simulations

Bergman-type medium range order in amorphous Zr77Rh23 alloy studied by ab initio molecular dynamics simulations

Structure and Density of Transition Metal-Metalloid Amorphous Alloys

ANNEALED CRYSTALLIZATION OF ULTRAFINE Ni-P AND Ni-Ce-P AMORPHOUS ALLOYS STUDIED BY XAFS