Abstract:The advantage of circulating fluidized bed (CFB) boilers in China is their ability to utilize low rank coal with low cost emission control. However, the new National Emission Regulation (NER) issued in early 2012 brings much more stringent challenges on the CFB industries, which also causes much attention from other countries. Based on the principle of a CFB boiler and previous operating experience, it is possible for the CFB boilers to meet the new NER and maintain the advantage of low cost emission control, while, more influences should be considered in their design and operation. To meet the requirement of the new NER, the fly ash collector should adopt a bag house or combination of electrostatic precipitator and bag filter to ensure dust emissions of less than 30 mg · Nm(-3). For SO2 emission control, the bed temperature should be strictly lower than 900 °C to maintain high reactivity and pores. The limestone particle size distribution should be ranged within a special scope to optimize the residence time and gas-solid reaction. At the same time, the injecting point should be optimized to ensure fast contact of lime with oxygen. In such conditions, the desulfurization efficiency could be increased more than 90%. For lower sulfur content fuels (<1.5%, referred value based on the heating value of standard coal of China), increasing Ca/S enough could decrease SO2 emissions lower than that of the new NER, 100 mg · Nm(-3). For fuels with sulfur content higher than 1.5%, some simplified systems for flue gas desulfurization, such as flash dryer absorber (FDA), are needed. And the NOx emissions of a CFB can be controlled to less than 100 mg · Nm(-3) without any equipment at a bed temperature lower than 900 °C for fuels with low volatiles content (<12%), while for fuels with high volatiles, selective non-catalytic reduction (SNCR) should be considered. Due to the unique temperature in CFB as well as the circulating ash, the efficiency of SNCR could reach as high as 70%. The Hg emission of CFB is very low for the new NER due to its innate property.

Effect of Fuel Heating Value on the Operation Performance of the 135 MWe Circulating Fluidized Bed Boiler

Impact of Coal Types and Pulverizing Methods on the Thermal Performance of Blending Coal-Fired Boilers and Their Operational Optimization

Operational Performance and Optimization of A 465t/h Cfb Boiler in China

Experimental Investigation on a 0.35 MWth Coal-Fired Horizontal Circulating Fluidized Bed Boiler

Effect of the Circulating Loop Performance on the Bed Temperature of a Circulating Fluidized Bed Boiler

Optimization of Fluidization State of a Circulating Fluidized Bed Boiler for Economical Operation

Development of Biomass-Fired Circulating Fluidized Bed Boiler with High Steam Parameters Based on Theoretical Analysis and Industrial Practices

Influence of the Coal Feed on the Bed Temperature Uniformity of a Large-sized CFB Boiler

Progress of circulating fluidized bed combustion technology in China: a review

Development and Technical Progress in Large-Scale Circulating Fluidized Bed Boiler in China

Comparative Analysis of Combustion Characteristics of a CFB Boiler during the Changes Process between High-Rated Loads and Low-Rated Loads

Operational Status of 300mwe CFB Boiler in China

Coal combustion efficiency in CFB boiler

Experimental Study on Coal Feeding Property of 600MW CFB Boiler

12Th International Conference on Fluidized Bed Technology DESIGN AND OPERATION OF A MSW AND STRAW CO-FIRING CFB BOILER

Effects of the Updated National Emission Regulation in China on Circulating Fluidized Bed Boilers and the Solutions to Meet Them.

Design and Development of a 660 MW High Efficiency Ultrasupercritical Double-furnace CFB Boiler

Field test of coal type adaptability on a 300MW CFB boiler

Research on Carbon Content in Fly Ash from Circulating Fluidized Bed Boilers

Retrofitting Strategy and Operating Technology of Pure Burning Zhundong Coal in a 135 MW Circulating Fluidized Bed Boiler

Research of Relationship Between CFBB Dynamic Behavior and Power and Coal Quality