Abstract:In this study, the process of surface morphology control was researched by combining the computation fluid dynamics (CFD) simulations and physical vapor transport (PVT) growth experiments. The results indicate the essentiality of preserving the surface structure of SiC substrate with macroscopic steps at the initial stage of the heterogeneous PVT growth. We identified an optimal range of growth temperature (Tg) and pressure to maintain the active Al vapor below a critical threshold. In the subsequent process, the pivotal factor for controlling the surface morphology of the AlN layer is identified as the supersaturation near the growing surface. Excessive supersaturation leads to a transition from a 2D to a 3D growth mode, resulting in a shift from a smooth to a rough surface morphology. An appropriate level of supersaturation can be achieved by carefully controlling the Tg, striking a balance between high surface quality and growth rate. Herein, we proposed a two-step PVT method for cultivating high-surface-quality AlN crystals on SiC substrates. At the first stage, the Tg is maintained below a threshold corresponding to the critical Al vapor pressure to preserve the surface structure until the SiC surface is completely covered by AlN. Then, Tg is elevated to near transition temperature (Ttran) to continue AlN single crystal growth at a proper rate for a long time, where Ttran is defined as the growth temperature at which the transition of the dominant mode from step growth to 3D growth happens. Two-inch-diameter AlN single crystals of thicknesses of nearly 1 mm with a smooth and lustrous surface have been obtained on SiC substrate by the two-step method.

Surface roughening as a precursor to the polymorphic transition in CBr4

A possible new solid phase observed from molecular dynamics study of CBr4

Transmission Electron Microscopy Investigation of the Micro-Defects in Czochralski Silicon

Surface roughening, premelting and melting of monolayer and bilayer crystals

Crystal-Crystal Phase Transformation Via Surface-Induced Virtual Premelting

Structural and electronic changes of SnBr4 under high pressure

High-pressure and high-temperature Raman study of cinnabar

Local order and orientational correlations in liquid and crystalline phases of carbon tetrabromide from neutron powder diffraction measurements

Surface effects in nucleation and growth of smectic B crystals in thin samples

Roughening Transition of Decagonal Quasi-Crystal in Undercooled Al72Ni12Co16 Alloy

Periodic Roughening Transitions in Diffusion-Limited Growth

Crystal surfaces with correlated disorder: Phase transitions between roughening and superroughening

Revealing Thermally-Activated Nucleation Pathways of Diffusionless Solid-to-solid Transition.

Molecular Dynamics Simulation of Nucleation of KBr Clusters Confined Within Armchair Single-Walled Carbon Nanotubes

Surface Control of AlN Single Crystal Growth on SiC Substrate

An Order–Disorder Transition in Surface Complexions and Its Influence on Crystal Growth of Boron-Rich Nanostructures

NTO Crystal Growth: From Fractal to Cube-shaped Structure

Surface Relief Accompanying Martensitic Transitions in an Fe-Ni-C Alloy by Atomic-Force Microscopy and Phenomenological Theory of Martensitic Crystallography

Crystal Growth in the Presence of Surface Melting: Novel Behavior of the Principal Facets of Ice

Structural heterogeneity and diffuse scattering in morphotropic lead zirconate-titanate single crystals

Impact of surface roughness on liquid-liquid transition