Abstract:Materials with pyrochlore structure A2B2O7 have attracted considerable attention owing to their various applications as catalysts, sensors, electrolytes, electrodes, and magnets due to the unique crystal structure and thermal stability. At the same time, the possibility of using such materials for electrochemical applications in salt melts has not been studied. This paper presents the new results of obtaining high-density Mg2+-doped ceramics based on Gd2Zr2O7 with pyrochlore structure and comprehensive investigation of the electrical properties and chemical stability in a lithium chloride melt with additives of various concentrations of lithium oxide, performed for the first time. The solid solution of Gd2−xMgxZr2O7−x/2 (0 ≤ x ≤ 0.10) with the pyrochlore structure was obtained by mechanically milling stoichiometric mixtures of the corresponding oxides, followed by annealing at 1500 °C. The lattice parameter changed non-linearly as a result of different mechanisms of Mg2+ incorporation into the Gd2Zr2O7 structure. At low dopant concentrations (x ≤ 0.03) some interstitial positions can be substituted by Mg2+, with further increasing Mg2+-content, the decrease in the lattice parameter occurred due to the substitution of host-ion sites with smaller dopant-ion. High-density ceramics 99% was prepared at Т = 1500 °С. According to the results of the measurements of electrical conductivity as a function of oxygen partial pressure, all investigated samples were characterized by the dominant ionic type of conductivity over a wide range of pО2 (1·10–18 ≤ pO2 ≤ 0.21 atm) and T < 800 °C. The sample with the composition of x = 0.03 had the highest oxygen-ion conductivity (10−3 S·cm−1at 600 °C). The investigation of chemical stability of ceramics in the melt of LiCl with 2.5 mas. % Li2O showed that the sample did not react with the melt during the exposed time of one week at the temperature of 650 °C. This result makes it possible to use these materials as oxygen activity sensors in halide melts.

Thermal Expansion and Defect Chemistry of MgO-Doped Sm2Zr2O7.

Effect of MgO Doping on the Thermal Conductivity of Sm2Zr2O7

Thermal Expansion and Defect Chemistry of MgO-Doped Sm2Zr2O7.

Thermal expansion coefficients of Sm2Zr2O7 doped with MgO

Thermal Expansion Coefficients of Sm<sub>2</sub>Zr<sub>2</sub>O<sub>7</sub> Doped with MgO

Structural Evolution and Thermophysical Properties of (smxgd1−x)2zr2o7 (0≤x≤1.0) Ceramics

The Gd2−xMgxZr2O7−x/2 Solid Solution: Ionic Conductivity and Chemical Stability in the Melt of LiCl-Li2O

Thermal Expansion and Thermal Conductivity of SmxZr1−xO2−x/2 (0.1 ≤ X ≤ 0.5) Ceramics

Effect of MgO/ZnO ratio on the formation process of MgxZn1-xO ceramics

Influence of Magnesia Doping on Structure and Electrical Conductivity of Pyrochlore Type Gdsmzr2o7

Effect of Ti Substitution for Zr on the Thermal Expansion Property of Fluorite-Type Gd2zr2o7

Influence of Zirconium (Zr4+) Substitution on the Crystal Structure and Optical and Dielectric Properties of Sr0.8Mg0.2(Sn1- xZrx)O3 Ceramics

Impact of Isovalent and Aliovalent Substitution on the Mechanical and Thermal Properties of Gd2Zr2O7

Structure of Magnesium Doped Yttrium Barium Zirconate as a Novel Compound

Electronic structure and thermal properties of Sm 3+ ‐doped La 2 Zr 2 O 7 : First‐principles calculations and experimental study

Phase equilibria in the La2O3-Sm2O3-ZrO2 system: Experimental studies and thermodynamic modeling

Molecular dynamics simulation of Sc2O3-Gd2O3-Y2O3 dopant effect on the crystal structure and thermophysical properties of zirconia-based ceramic materials

Thermal expansion in solid solution Er2-xSmxW3O12

Investigation on mechanical and thermal properties of MgAl2O4-Mg2TiO4 solid solutions with spinel-type structure

A promising Sm1.9Ca0.1Zr2O6.95 ceramic for thermal barrier coatings

Phase Composition, Crystal Structures and Enhanced Microwave Dielectric Properties of Mg2+/Zr4+ Co-Doped Al2Mo3O12 Ceramics