Abstract:The growth of high-quality ZnO bulk crystals is an outstanding challenge, and the nature of grown-in defects in crystals is far from well understood. In this work, a specially designed low-temperature-gradient CVT growth system was developed based on finite element analysis. High-quality ZnO single crystals were successfully grown. The supersaturation front in the growth system was controlled, and internal stress in the crystal was reduced by introducing a radiation baffle and a special seed pedestal. The structural, electrical, and optical properties of ZnO crystals were studied before and after oxygen annealing. The scanning electron microscope (SEM) and optical microscope (OM) results indicate the stable growth is achieved under the Zn-rich growth condition. The X-ray rocking curve measurements reveal the high crystalline quality of the grown crystal with the full-width at half-maximum (FWHM) value of 17 arcsec for the (004) reflection. The time-of-flight secondary ion mass spectroscopy (ToF-SIMS) results prove the high purity of grown crystals and reveal the variations of trace impurity concentrations in crystals. When annealed in oxygen at 1000 °C, the optical band gap (Eg) changes from 2.50 eV to 3.15 eV. The Raman analysis indicates that oxygen vacancies (Vo) in the as-grown crystal disappear after annealing. The Hall measurements show that the room temperature (RT) mobilities before and after annealing are 197 cm2V−1c−1 and 207 cm2V−1c−1, respectively. The RT carrier concentration decreases by about two orders of magnitude to 5.45 × 1015 cm−3, while the RT resistivity increases by about one order of magnitude to 5.57 Ω cm after annealing. The positron annihilation lifetimes (PALS) results prove the presence of Zn vacancies (Vzn) after annealing. The origins of as-grown ZnO green luminescence (GL) and the temperature-dependent blue shifts of the GL peak positions are explained based on Zni and Vo defects. The fine structures of annealed ZnO GL are found to be related to Vzn native defects rather than Cu impurity.

Low-temperature growth and optical properties of radial ZnO nanowires

Effect of Nucleation and Growth Kinetics on the Electrical and Optical Properties of Undoped ZnO Films

Low-Temperature Growth and Properties of Zno Nanowires

STRUCTURAL AND OPTICAL STUDIES OF ZnO FILMS GROWN AT LOW TEMPERATURE

Growth And Characterization Of Cu-Catalyzed Zno Nanowires

Low-temperature growth of uniform ZnO particles with controllable ellipsoidal morphologies and characteristic luminescence patterns.

Low temperature growth and properties of ZnO nanorod arrays

Low Temperature Synthesis and Optical Properties of Small-Diameter ZnO Nanorods

Preparation and Photoluminescence of ZnO with Nanostructure by Hollow-Cathode Discharge

On the formation of well-aligned ZnO nanowall networks by catalyst-free thermal evaporation method

Growth and Electrical Properties of Zinc Oxide Nanowires.

A Novel Low-Temperature Method to Grow Single-Crystal Zno Nanorods

Large-Scale Synthesis of Zno Nanowires Using A Low-Temperature Chemical Route and Their Photoluminescence Properties

Low-temperature Growth and Raman Scattering Study of Vertically Aligned ZnO Nanowires on Si Substrate

Tempererature-Controlled Growth Of Zno Nanostructures: Branched Nanobelts And Wide Nanosheets

Growth and Properties of ZnO Nanorod and Nanonails by Thermal Evaporation

Characterization of zinc oxide crystal nanowires grown by thermal evaporation of ZnS powders

Synthesis of radial ZnO nanostructures by a simple thermal evaporation method

Crystal growth, finite element analysis and oxygen annealing of ZnO bulk crystal grown by low-temperature-gradient chemical vapor transport

Low-temperature synthesis of ZnO nanonails

Growth mechanism and diameter control of well-aligned small-diameter ZnO nanowire arrays synthesized by a catalyst-free thermal evaporation method.