Abstract:A series of Ni-SiO2 aerogel and xerogel catalysts were prepared by sol-gel supercritical drying (SCD) and general drying methods using tetraethylorthosilicate (TEOS) as a precursor of silica and nickel nitrate as starting material of nickel. Water or alcohol was used as solvent. Based on the experimental results of nitrogen adsorption-desorption, XRD, temperature-programmed reduction (TPR), IR, temperature-programmed desorption of hydrogen (H-2-TPD) and activity evaluation, the physical and chemical properties and catalytic performance of the catalysts for hydrogenation of m-dinitrobenzene to m-phenylenediamine were investigated. Both the Ni-SiO2 aerogel catalysts had high specific surface areas, but their catalytic activity and selectivity were low due to their small active surface areas caused by sintering of nickel crystallite. For the Ni-SiO2 xerogel catalyst that used alcohol as solvent, well-dispersed nickel particles were formed, but the strong interaction between nickel and the support made the catalyst difficult to be reduced, thus resulting in lower degree of the utilization of metal. However, the xerogel catalyst that made use of water solution exhibited the highest catalytic activity and selectivity for m-phenylenediamine attributed to its higher surface area of active nickel, over which the conversion of m-dinitrobenzene and the yield of m-phenylenediamine were up to 92.6% and 88.4%, respectively, under the conditions of 2.6 MPa and 373 K after reaction for 1 h.

Study on Hydrogenation of Gum Rosin Catalyzed by Ni/ Al2 O3 - Mx O Y

Sol-Gel Preparation, Characterization and Hydrogenation Property of Silica Supported Ni Catalyst

Study on the Ni Supported Catalysts Used for Hydrogenation of IPN to Produce MXDA

Study on Regeneration of the Deactivated Catalyst Ni/Al2O3-MxOy Used for Hydrogenation of Gum Rosin.

A Study on Catalytic Conversion of Biomass-Derived Carbohydrates to Methyl Lactate by NiO in Near-Critical Methanol

Hydrogenation of Levulinic Acid over Nickel Catalysts Supported on Aluminum Oxide to Prepare Γ-Valerolactone

Study on Deactivation and Regeneration of Ni-loaded Nanocatalyst for Disproportionation of Gum Rosin

Hydrogenation of coal tar on NiMoP/γ-Al2 O3 catalyst

Study on Reaction Kinetics of Rosin Disproportionation Catalyzed by Non-Noble Metal

Studies on Ni/Al2O3 Catalyst for Hydrogen Production from Ethanol Steam Reforming

Hydrogenation of fatty acids to fatty alcohols over Ni 3 Fe nanoparticles anchored on TiO 2 crystal catalyst: Metal support interaction and mechanism investigation

Preparation of Ni/TiO2-Al2O3 Catalyst and Its Application in Catalyzing Hydrogenation of Turpentine

Promotion of Ni/MCM-41 Catalyst for Hydrogenation of Naphthalene by Co-Impregnation with Polyols

Research on in Situ Hydrogenation of O-Cresol over Ni/CMK-3 Catalysts

Influence of the Sol-Gel Method on a NiO/Al2O3 Catalyst for CH4/O2 to Syngas Reaction

The study of catalytic reforming of coke oven gas producing hydrogen-rich gas

Preparation of Raney Ni Catalyst and Research on Its Catalytic Hydrogenation Performance for Alkenyl Aromatics

Colloidal and Nanosized Catalysts in Organic Synthesis: XXVII.1 Hydrogenation of Carbonyl Compounds in the Presence of Supported Nickel Catalysts

Partial Oxidation Of Methane To Syngas Over Ni-Based Catalysts

Effects of Preparation Method on the Performance of Ni/Al 2 O 3 Catalysts for Hydrogen Production by Bio-Oil Steam Reforming

Revealing the Effects of Mo Doping to Ni on Catalyzing Hydrogenation of Fatty Acids to Fatty Alcohols