Abstract:The SO2/NOX pollution in the flue gas of non-ferrous smelting is increasingly serious. At the same time, the accumulation of red mud (RM) in the aluminum industry and phosphorus sludge (PS) in the yellow phosphorus industry has caused serious harm to the environment. To remove SO2 and NOX from the non-ferrous smelting flue gas and realize the resource utilization of the above two solid wastes, an ultrasonic field was used in this study to strengthen the PS excited O3 process and RM wet desulfurization and denitrification process. In the process of O3 excitation, the response surface method (RSM) is used to obtain the optimal O3 excitation concentration, and the optimal reaction conditions are designed based on the response surface optimization model: T is 53.226 °C, power density is 0.4 W/cm2, PS concentration is 51.433 g/L, O3 formation concentration up to 250 ppm or more, which provides a theoretical basis for subsequent desulfurization and denitrification steps. It is proved that this study can replace the expensive traditional O3 generator and provide a basis for NOX removal in the following process. In addition, the optimum experimental conditions of ultrasonic enhanced RM desulfurization and denitrification process were also explored. Under ultrasonic frequency of 28 kHz, ultrasonic power density of 0.4 W/cm2, T of 50 °C, RM concentration of 15 g/L, and stirring intensity of 1000 rpm, the desulfurization efficiency of the reaction system can be maintained above 95 % within 250 min, and the denitrification efficiency can be maintained above 90 % within 250 min. The effect of desulfurization and denitrification in this study is much better than that of traditional methods. Finally, the reaction mechanism of ultrasonic enhanced O3 excitation and RM wet desulfurization and nitrogen removal was discussed by combining adsorption thermodynamics, isotherm, and kinetics. The results showed that the OH· free radicals generated by ultrasonic cavitation and the physical effects brought by emulsification had significant promoting effects.

Study on the collaborative removal of multi-pollutants from flue gas

Development Of Multi-Pollutants Control Technology For Flue Gas From Power Plants In China

A002 DEVELOPMENT OF MULTI-POLLUTANTS CONTROL TECHNOLOGY FOR FLUE GAS FROM POWER PLANTS IN CHINA(Plenary Lecture)

Fundamentals and Environmental Applications of Non-thermal Plasmas: Multi-pollutants Emission Control from Coal-Fired Flue Gas

A Semi-Wet Technological Process for Flue Gas Desulfurization by Corona Discharges at an Industrial Scale

Novel Method for High-Performance Simultaneous Removal of NOx and SO2 by Coupling Yellow Phosphorus Emulsion with Red Mud

A Superior Liquid Phase Catalyst for Enhanced Absorption of NO2 Together with SO2 after Low Temperature Ozone Oxidation for Flue Gas Treatment

Influences of Water Vapor and CO2 on NOx Removal by Plasma-facilitated Selective Catalytic Reduction

Experimental Research for Multi-Pollution Control by Ozone and by-Product Purification

O3 oxidation combined with semi-dry method for simultaneous desulfurization and denitrification of sintering/pelletizing flue gas

Synergistic removal of particles, SO2, and NO2 in desulfurized flue gas during condensation

Plasma-catalyzed combined dynamic wave scrubbing: A novel method for highly efficient removal of multiple pollutants from flue gas at low temperatures

Ultrasonic-enhanced Phosphorus Sludge Excited O3 Coupled Red Mud Simultaneous Desulfurization and Denitrification

Device and method for removing sulfur trioxide from coal-fired flue gas

Front multi-pollutant oxygen spraying cooperative control system and method

The simultaneous removal of SO2 and NO from flue gas over activated coke in a multi-stage fluidized bed at low temperature

Promoting the synergistic removal of SO 3 aerosols and particles during the flue gas condensation by combining alkali spray and turbulent agglomeration

Novel Simultaneous Removal Technology of NO and SO2 Using a Semi-Dry Microwave Activation Persulfate System

Simultaneous removal of SO2 and NOx by a corona radical shower system

Studies on Simultaneous Catalytic Removal of NOX and SO2

Review on Removal of SO2, NOx, Mercury, and Arsenic from Flue Gas Using Green Oxidation Absorption Technology