Abstract:The thermal oxidation of molten SnCl2 leads to the formation of SnO2 nanocrystals of less than 50 nm in diameter at 600 degrees C. These nanoparticles grow to large crystals with sizes of up to 10 um by increasing the heat-treatment temperature to 800 degrees C. The excessive growth of SnO2 crystals can be prevented by the introduction of polyethylene terephthalate (PET) and inorganic salts, through which SnO2@carbon nanocomposites could be prepared in a fast and clean way. Increasing the heat-treatment temperature from 600 to 800 degrees C leads to the enhancement of the crystalline quality of SnO2 present in the nanocomposites, while the excessive crystal growth at high temperatures is prevented. A large number of highly-crystalline SnO2 nanocrystals with sizes of less than 5 nm embedded in carbon substrate could be detected in the nanocomposite material prepared at 800 degrees C. The prepared sample exhibits an interesting combination of dye adsorption, with the capacity of 63 Mg-dye/g(nano-composite), as well as photocatalytic performance under normal sunlight irradiation toward the removal of methylene blue. This article suggests a clean and fast strategy for the preparation of highly crystalline SnO2 amorphous carbon nanocomposites.

Preparation of Nanometer-Sized Sno2 by the Fusion Method

Sub-2 Nm SnO2 Nanocrystals: A Reduction/oxidation Chemical Reaction Synthesis and Optical Properties

Solvothermal Synthesis of Grain Size Controlled Nanocrystalline Sno2

PREPARATION OF NiO NANOPARTICLES ON THE SILICA SURFACE BY ADSORPTION PHASE SYNTHESIS AND ITS REGULATION ON MORPHOLOGY OF NiO PARTICLES

Preparation of AgSnO2 Nano-Composite Powder by Wet Chemical Method

A novel method to prepare nanocrystalline SnO2

Preparation of AgSnO_2 nano-composite powder by wet chemical method

Preparation of Sno2 Nanowires Synthesized by Vapor-Solid Mode and Its Growth Mechanism

Fast and Clean Preparation of Highly Crystalline SnO2 Nanoparticles Incorporated in Amorphous Carbon, and Its Dye Removal Performance

A Novel Solvothermal Synthesis of High-Surface-Area Sno2 Nanocrystals

Controllable Low-Temperature Hydrothermal Synthesis and Gas-Sensing Investigation of Crystalline SnO 2 Nanoparticles

Preparation and Characterization of Sno2 Nanoparticles with A Surfactant-Mediated Method

Synthesis and Growth Mechanism Study of SnO2 Micro/nanomaterials

Large-Scale Synthesis of Sno2 Nanobelts

Size-Controllable One-Dimensinal Sno2 Nanocrystals: Synthesis, Growth Mechanism, And Gas Sensing Property

Size-controlled synthesis and characterization of quantum-size SnO2 nanocrystallites by a solvothermal route

Synthesis of Sn Nanoparticles and Their Size Effect on the Melting Point

Preparation of ZnO/SiO_2 Nanoparticle by Adsorption Phase Reaction Technique

Rapid synthesis of nanocrystalline SnO2 powders by microwave heating method

Preparation of SnO2 nanorods by annealing SnO2 powder in NaCl flux

Size-Dependent Optical Properties of SnO2 Nanoparticles Prepared by Soft Chemical Technique