Abstract:In this work, experiment was conducted to examine the thermo-physical properties of an alternative refrigerant to HCFC-22 in the presence of polyol ester (POE). The new alternative refrigerant is a mixture of HFC-32/125/161, whose physical properties are similar to HCFC-22 but has a lower global warming potential (GWP) than that of R407C. POE is used as the tested lubricating oil in the experiment. The saturated vapor pressure data and vapor–liquid equilibrium data of nine different mass fractions of the new refrigerant and polyol ester (POE) in the temperature range of 253–323K were measured by single-phase cycle method. The experiment results showed that there was no stratification, no sediment generation in the liquid phase of the mixture, and the color of liquid phase of the mixture had no change in the equilibrium cell before and after the experiment with the POE concentration greater than 20% and the temperature higher than 258K; with POE concentration lower than 20% and temperature lower than 258K, stratification began to appear. Meanwhile, when POE and the refrigerant were miscible, the saturated pressure data of the mixture (HFC-32/125/161+POE) revealed that POE had a very small impact on saturated vapor pressure of the mixture (almost negligible) when POE was less than 10% of the mixture; POE has an obvious effect on the saturated vapor pressure of the mixture when there is more than 10% POE in the mixture, especially when the temperature is higher than 283.15K. Experimental data were correlated by Flory–Huggins model, Heil model, NRTL model and Wilson model. The results showed that to the average and maximum pressure deviation, the results were better with considering the effects of temperature on the energy parameters. Among the above models, the NRTL activity coefficient model was the best, the Heil and Wilson models followed and the Flory–Huggins model had the largest deviation from the experimental data.

Experimental investigation on the mutual solubility of R134a/R290 with lubricant

Solubility And Miscibility For The Mixture Of (Ethyl Fluoride Plus Polyol Ester Oil)

STUDY ON L-DRB/A15 FULL-CLOSED REFRIGERATOR OIL

Experimental Investigation on the Solubility of R290 in Two Mineral Oils

Solubility and Miscibility for the Mixture of (ethyl Fluoride + Alkylbenzene Oil)

Investigation on the Vapor–Liquid Equilibrium for the Ternary Mixture HFC-32 + HFC-125 + HFC-161 at Temperatures from 265.15 K to 303.15 K

Research progress of the compatibility between alternative refrigerant/oil and materials

Experimental Study on the Oil Return Characteristics of Miscible or Partially Miscible Oil in R290 Room Air Conditioners

Experimental Study on Miscibility of R134a/R600a Refrigerant and Mineral Oil Mixture

Experimental Analysis on R290 Solubility and R290/oil Mixture Viscosity in Oil Sump of the Rotary Compressor

Experimental Data and Description of the Phase Equilibrium in the Binary System of Ethyl Fluoride and Polyol Ester Oil (planetelf ACD 32)

Performance and Refrigerant Mass Distribution of a R290 Split Air Conditioner with Different Lubricating Oils

The miscibility of DME and DME/R125 and lubricant oil

Experimental studies on a mixture of HFC-32/125/161 as an alternative refrigerant to HCFC-22 in the presence of polyol ester

Oil Solubility Effect on Evaporation Performance with R290 As Refrigerant

Vapor-liquid Equilibrium Measurement and Heating Performance Modeling on Eco-Friendly Zeotropic Blends of CO2/R1234ze(Z) and CO2/R1336mzz(E)

The Influence of Nanoparticles on the Miscibility of R134a and Mineral Oil

Oil Retention and Its Mass Distribution Within a R290 Room Air Conditioner Using Miscible or Partially Miscible Oils

STUDY OF THE APPLICATION OF R134a/R600a MIXTURE IN REFRIGERATOR

Refrigerant migration and oil sump viscosity change of R290 high-pressure rotary compressor during shutdown process

Investigation of solubility behavior between HFO1234yf and lubricants