Abstract:The corrosive water environment has a decisive influence on the durability of a diversion tunnel lining. In this paper, the effects of carbonation on cement-based materials in water-immersion and saturated-humidity environments were studied by increasing the CO2 concentration. The results show that under conditions of water-immersion and saturated humidity, the color of the non-carbonation region is dark, while the carbonation region is gray, and the color boundary is obvious. However, in an atmospheric environment, there is no zone with a dark color and the color boundary is not obvious. In a saturated-humidity environment, the carbonation depth increases over time and changes greatly, and its value is about 16.71 mm at 200 days. While in a water-immersion environment, the carbonation depth varies little with time and the value is only 2.31 mm. The carbonation depths of cement mortar samples in different environments generally follow a linear relationship with the square root of time. The carbonation coefficient in a saturated-humidity environment is more than nine times that in the water-immersion environment. In a water-immersion environment, the carbonation causes a large loss of calcium in cement-based materials, and their Ca/Si ratio obviously decreases. The calcium silicon ratio (Ca/Si) of cement-based materials in a water-immersion environment is 0.11, which is much less than 1.51 in a water-saturated environment and 1.49 in an atmospheric environment. In a saturated-humidity environment, the carbonation only reduces the pH of the pore solution in the carbonation region, and the structural stability of cement-based materials is not degraded. The number of pores of all radii after carbonation in a water-immersion environment exceeds that in a saturated-humidity environment, and the total pore volume and average pore radius in a water-immersion environment are also larger than in a saturated-humidity environment, so the water-immersion environment accelerates the development and expansion of pores. The research results can provide some theoretical and technical support for the design, construction, and safe operation of diversion tunnel linings.

Tracing carbonation in cementitious slurry using anthocyanin extracted from fresh or stale petals

Use of a novel pH indicator extracted from petals to investigate the carbonation behavior in cementitious materials

Development and Application of Cinnamaldehyde-Loaded Halloysite Nanotubes for the Conservation of Stone Cultural Heritage

Application of Infrared Spectroscopy in the Measurement of Carbonation Depth of Concrete

Capillary Imbibition of Ethanol in Cement Paste Traced by X-ray Computed Tomography with CsCl-enhancing Technique

Preparation aragonite whisker-rich materials by wet carbonation of cement: Towards yielding micro-fiber reinforced cement and sequestrating CO2

Quantitative evaluation of cement paste carbonation using Raman spectroscopy

Research on Sustainable Development of Fine-Grained Material Cement Slurry

Carbonation Process Simulation for Cement-Based Materials Based on Microstructure by a Cement Hydration Model

Comparison of detection methods for carbonation depth of concrete

Microstructure Modification of Carbonated Cement Paste with Six Kinds of Modern Microscopic Instruments

Phase assemblance evolution during wet carbonation of recycled concrete fines

Description of the concrete carbonation process with adjusted depth-resolved thermogravimetric analysis

Development of more accurate methods for determining carbonation depth in cement-based materials

Quantification of carbonated Mg-based cement pastes by Raman spectroscopy

Real-time in situ visualization of internal relative humidity in fluorescence embedded cement-based materials

Mechanism Analysis on Carbonation of Hardened Cement Paste with XCT

Optical pH imaging reveals what phenolphthalein conceals – A carbonation study on blended cements

Experimental Study on Carbonation of Cement-Based Materials in Underground Engineering

Multi technique characterization of the carbonation affected zone including non-destructive single sided 1 H NMR

Carbonation of photocatalytic aluminosilicate cement composites: Evolution of self-cleaning and radiative cooling properties