Improving Mg 2+ /Li + separation performance of polyamide nanofiltration membrane by swelling-embedding-shrinking strategy

Hengyu Li,Yunhao Li,Meng Li,Yan Jin,Guodong Kang,Yiming Cao
DOI: https://doi.org/10.1016/j.memsci.2022.121321
IF: 9.5
2022-12-28
Journal of Membrane Science
Abstract:Extraction of lithium from salt lakes is an important route for lithium sources. Due to the unique structure and separation mechanism, i.e., size exclusion and Donnan effect, Nanofiltration (NF) is considered as a promising way to separate magnesium (Mg 2+ ) and lithium (Li + ) ions. However, the Mg 2+ /Li + separation factor of NF membrane fabricated by traditional interfacial polymerization (IP) is usually dissatisfactory. Here, a swelling-embedding-shrinking strategy was proposed to modify polyethyleneimine (PEI)/trimesoyl chloride (TMC) NF membranes using diethylenetriamine (DETA) to improve the performance in Mg 2+ /Li + separation. The pristine PEI/TMC NF membrane was swollen with methanol to increase the polyamide chain spacing followed by embedding electropositive DETA as a modifier. The charge properties and pore structure of the active layer could be regulated by optimizing the modification conditions. Within comparison to the pristine membrane (TFC-0), the pure water flux of modified NF membrane (TFC-3) increased by 63.6% because of the rougher surface and the larger pore size. Meanwhile, the embedding of electropositive DETA reduced the electronegative property of membrane surface. In consequence, TFC-3 membrane exhibited higher rejection of MgCl 2 (93.9% against 88.4%) and lower rejection of LiCl (31.0% against 32.1%), thus showing a twofold improvement in Mg 2+ /Li + separation factor ( S Li, Mg = 11.38 against 5.87). The swelling-embedding-shrinking strategy in this article provided a good reference for the modification of NF membranes in the separation of multivalent and monovalent ions.
engineering, chemical,polymer science
What problem does this paper attempt to address?