Abstract:The segregation behaviors of fine coal particles in a coal beneficiation fluidized bed (CBFB) were investigated in this work. The size range of 1–8mm was taken into account and three separate size fractions were studied comparatively in the experiments, e.g. 1–2mm, 3–5.5mm and 5.5–8mm. Both a clean coal sample and a gangue sample were used as the processed material to study the segregation behaviors of both light particles and heavy particles. The dense bed was divided as seven layers from bottom to top and the particle distribution in each layer for each sample was fully demonstrated. The influences of the particle density, particle size and the fluidized air velocity were revealed, the segregation patterns under different conditions were compared and the segregation mechanism was carefully analyzed. The results showed that the flotation and sedimentation of the particles in CBFB were still largely influenced by the particle density for the fine size range particles, and density stratification occurred even within each size fraction sample. The weight fraction in each layer showed a quadratic increase along the bed height for the coal particles. For gangue particles, a large fraction deposited in the bottom while the mass proportions in the middle layers also showed an increased tendency. With a decrease of the particle size, both the particle segregation and the density stratification phenomena deteriorated seriously. It was proved that particle feed size should be above 3mm as the separation effect was quite inefficient for finer particles. By increasing the fluidized air velocity, the bed density slightly decreased but the bed turbulence was largely strengthened by the increasing bubble boiling effect. The flotation and sedimentation of the particles in 5.5–8mm were obviously affected while no clear influence occurred to the rest of the two size fractions. Moreover, the results in this work provide a group of data that are quite suitable for CBFB numerical modeling studies.

Vibration-induced segregation characteristics of binary pebble beds in confined containers

Estimating the segregation of a granular bed subjected to vibration in various modes

Investigation of particle segregation in a vertically vibrated binary mixture: Segregation process and mechanism

DEM simulation of size segregation of binary mixtures of cohesive particles under a horizontal swirling vibration

DEM Study of the Size-Induced Segregation Dynamics of a Ternary-Size Granular Mixture in the Rolling-Regime Rotating Drum

Research on Separation Mechanism of Liquid-Solid Fluidized Bed Separator

A Numerical Investigation on Segregation in Gas-Fluidized Beds of Short, Flexible Fibers

Segregation and mixing of binary mixtures of spherical particles in a bubbling fluidized bed

Three Dimensional DEM/CFD Analysis of Segregation During Silo Filling with Binary Mixtures of Different Particle Sizes

Particle segregation within bidisperse turbidity current evolution

DEM investigation of the axial dispersion behavior of a binary mixture in the rotating drum

Reducing segregation in vibrated binary-sized granular mixtures by excessive small particle introduction

Investigation of the Vibration Sorting of Non-Spherical Particles Based on DEM Simulation

Near-Infrared Identification of the Dimmest X-ray Sources on the Galactic Plane with the ESO/NTT SOFI Camera

Numerical and Experimental Study of Radial Segregation of Bi-Disperse Particles in a Quasi-Two-dimensional Horizontal Rotating Drum

Effect of bed density on the segregation behavior of fine coal particles (<6 mm) in a gas–solid separation fluidized bed

Horizontal Segregation in a Vertically Vibrated Binary Granular System.

Sandwich-Like Segregation in Vertically Vibrated Binary Granular Mixtures

Micro-scale Simulation and Analysis of Gas-Solid Fluidized Bed with Multi-Density Distribution of Particles

The segregation behaviors of fine coal particles in a coal beneficiation fluidized bed